Raypak CROSSWIND Series User Manual

Catalog No. 6100.64
E󰀨ective: 11-15-19
Replaces: New
P/N 241827 Rev.1
INSTALLATION
AND OPERATION
MANUAL
FOR YOUR SAFETY: Do not store or use gasoline or other ammable vapors and
liquids or other combustible materials in the vicinity of this or any other appliance. To
do so may result in an explosion or re.
Crosswind
Side Discharge
Heat Pump Pool Heater
NOTE: The instructions in this manual are for the use of qualied individuals specially trained and experienced
in the installation and maintenance of this type of equipment and related system components. Installation and
service personnel are required by some states to be licensed. Persons not qualied shall not attempt to install,
service, or maintain this equipment.
This manual should be maintained in legible condition and kept adjacent to the heat pump pool heater or in a
safe place for future use.
Inverter Models
CROSSWIND-30-I through -65-I
On/O󰀨 Models
CROSSWIND-40-O through -65-O
(Canada Only)
6100.64_Crosswind.indd 1 11/26/2019 4:16:40 PM

Raypak CROSSWIND Series Specifications

General

Category	Swimming Pool Heater
Brand	Raypak
Fuel Type	Natural Gas or Propane
Series	CROSSWIND
Water Flow Rate	20 - 120 GPM
Warranty	5 years

Summary

Warnings and Safety Precautions

Understanding Hazard Alert Terms

Explains the meaning of hazard alert symbols used in the manual.

General Safety Precautions

Provides essential guidelines for safe operation and handling of the heater.

Water Chemistry Guidelines

Pre-Installation Considerations

Installation Site Considerations

Details optimal placement and environmental factors for heater installation.

Installation Site Requirements

Outlines necessary clearances, base requirements, and external conditions.

Electrical Wiring and Connections

Wiring and Electrical Connection Guidelines

Covers guidelines for safe and compliant electrical installation by a licensed electrician.

Automation Control Wiring

Details the 2-wire system connection for temperature automation control.

Wiring Diagrams

Inverter Models Wiring Diagrams

Presents wiring diagrams for Crosswind 30-I, 40-I, and 50-I models.

Crosswind 65-I Wiring Diagram

Provides the specific wiring diagram for the Crosswind 65-I model.

On/Off Models Wiring Diagrams

Shows wiring diagrams for Crosswind 30-O and 40-O models.

Crosswinds 50-O Wiring Diagram

Presents the wiring diagram for the Crosswinds 50-O model.

Controls and Operation

Inverter Model Controls and Operation

Explains the operation display, buttons, screen lock, and defrosting for inverter models.

On/Off Model Controls and Operation

Details the display, buttons, and settings for On/Off models.

Operating Instructions

Initial Start-Up Procedures

Guides on initial startup, including model identification, water flow, and power on.

Routine Maintenance and Seasonal Preparation

Covers routine maintenance, cleaning, and preparation for cold weather.

Pre-Use Testing and Checks

Outlines inspection steps before using the heater.

Troubleshooting Common Faults

Fault Codes and Solutions

Lists common failures, reasons, and solutions for the heat pump.

Technical Parameters

Inverter Model Specifications

Provides detailed technical data and specifications for inverter models.

On/Off Model Specifications

Lists technical parameters and specifications for On/Off models.

Replacement Parts Information

Illustrated Parts Lists

Inverter Models Parts Breakdown

Visual breakdown and part numbers for inverter model components.

On/Off Models Parts Breakdown

Visual breakdown and part numbers for On/Off model components.

Warranty Details