Raytheon Beech Baron E55 - Page 886

RByCheOll
AiKraft
Company
BARON
55
AND
58
SHOP
MANUAL
100-HOUR
INSPECTION
(Continued)
F.
NOSESECTION
MECH
INSP
1.
SKIN
Inspect
skin
for
corrosion, condition,
and
loose
or
missing
rivets.
If
damage
is
found,
check
adjacent
structure.
2.
STRUCTURE
Check
for
corrosion,
cracks,
loose
or
missing
rivets,
and
concealed
damage.
3.
RADAR
ANTENNA
COVER
Check
the
fiberglass
for
security,
attachment
and
cracks.
4.
BATTERY
Inspect
for
clean,
tight
connections
and
correct
fluid
level. Add
distilled
water
as
required. Inspect
vent
hose
at
battery
box
for
obstructions. The
battery
box
should be washed
out
thoroughly
and
dried
each time
the
battery
is
removed
5.
BRAKE FLUID
RESERVOIR Check reservoir for
security,
attachment,
open
vent,
proper
fluid level
and
for
leaks.
6.
ELECTRICAL
WIRING
AND
EQUIPMENT
Inspect
electrical
wiring
and
associated
equipment
and accessories for
condition,
fraying,
and attachment.
7.
HEATER
FUEL
SYSTEM Check
lines
for
connection and
chafing.
8.
HEATER
DUCTING
AND
WIRING Check
for
security
and
chafing.
9.
AIR
CONDITIONER
EVAPORATOR Check
for
condition and
secure
attachment.
10.
HEATER
IRIS
VALVE
Check
for smooth
operation.
11. PROPELLER
ANTI-ICE RESERVOIR
AND
PLUMBING
Check
for
security
and
unobstructed
lines.
Fill
reservoir
as
necessary.
12.
OXYGEN
Check
for condition
and
attachment.
13.
TAXI
LIGHT
Check
for
security
and
operation. Replace
if
necessary.
14.
BAGGAGE
DOOR Check for
condition and
proper
latching.
15.
PITOT
MAST
(TC-1608
and
After; TE-938,
TE-942
and
After;
TH-1
and
After)
Check
for
condition and obstruction.
16.
JANITROL
COMBUSTION
HEATER
(TC-1658
and
After;
TE-959,
TE-968
and
I
After;
TH-437 and
After)
Inspect
per
Janitrol Heater Manual
P/N
24E25-1
orsubsequent.
G.
REAR
FUSELAGE
AND
EMPENNAGE
1.
SKIN
Check
for
deformation,
cracks and obvious
damage.
Check
for
loose
or
missing
rivets.
If
damage
is
found,
check
adjacent
structure.
2.
STRUCTURE
Inspect
the
two
most
aft bulkheads for
cracks, distortion,
loose
rivets
or
other obvious
damage.
Page
12Dec
31/04
SECTION
16