RC Mowers TK-44E - Troubleshooting

STORAGE
SHORT-TERM STORAGE
IMPORTANT: NEVER wash unit with high-pressure
water or store outdoors.
1. Allow unit to cool and clean with mild
soap
and water.
2. Tighten all hardware to correct
specifications.
3. Inspect unit for visible signs of wear or
damage. Repair as needed.
4. Prepare fuel system for storage.
NOTICE: RC Mowers recommends using a
quality fuel stabilizer in all fuel. Gasoline left in
the fuel system without a stabilizer, even
for
short periods of time, deteriorates and leaves
gummy deposits in the system that may cause
damage. For the best effectiveness, add
stabilizer to all fuel
containers whenever
purchasing fuel. Add
the stabilizer to the
container before adding
fuel.
a. Add fuel stabilizer according to
manufacturer's instructions to the
fuel
tank and any fuel containers with
remaining fuel.
b. Operate engine outdoors for at least
5 minutes to allow stabilizer to reach
the carburetor.
5. Turn key to off position and remove from
ignition.
6. Store unit in a cool, dry, protected area.
DO NOT store unit outdoors.
LONG-TERM STORAGE
1. Perform short-term storage procedures.
2. Lubricate as directed in Lubricate Unit on
page
19.
3. Touch-up all scratched painted surfaces.
4. Remove and charge battery as directed in
Charge Battery on page 21. Store battery in
a cool, dry, protected area.
5. Store unit in a cool, dry, protected area.
DO
NOT store unit outdoors.
START-OF-SEASON PREPARATION
1. Before adding fuel for the first time after
long-term storage, add fresh, stabilizer-
treated fuel to fuel tank and any fuel
containers with remaining fuel.
2. Charge and install the battery.
ACCESSORIES
See RC Mowers for a complete list of compatible
accessories and attachments for
your unit.
SPECIFICATIONS
Model Number TK-44E
Description
44" Tracked Unit
Engine Kawasaki FR65IV
Displacement – cm
3
(in
3
)
726
Maximum RPM – No Load 3600 +100/
Oil Capacity Refer to engine manual.
Liquid or Air Cooled Air
Electrical
Starter Electric
Battery
12-Volt Maintenance-Free,
300 CCA 10U1L
PTO (Power Take-off)
Electric PTO Clutch / Brake
Fuel
Tank Capacity – liter (gal)
19.3 (5.1)
Type Refer to engine manual.
Transmission
Type
Hydrostatic Drive
Oil
Use 15W-50 synthetic
motor oil or equivalent
Hydraulic Oil Filter Yes
Drive Speed
Forward Maximum – mph
6
Reverse Maximum – mph
3
Turning Radius
Zero
Brakes
Parking
Mower Deck
Cutting Height – in inches
1.5 – 5.0
Cutting Height
Increments – cm (in)
0.635 (0.25)
Cutting Width – cm (in) 111.8 (44)
Deck Lift Mechanical Pin Lock
Size and Weight
Length – cm (in)
Width – cm (in)
Height – in inches
47
Weight – kg (lb)
(Pending)
33