Skyjack SJ 9250 - Table 4.8 Operators Checklist

Mid Size & Full Size RTs
Engine Powered
Page 69
Section 4 Tables
Table 4.8 Operator’s Checklist
INSPECTION FRE
Q
UENCY
P
F
R
NA
N/A P F R N/A P F R
Function Tests
60604AD-AS-R
Test Main Power Disconnect Switch
Test Emergency Stop
Test Base Lift Enable
Test Lower/Neutral/Raise Switch
Test Emergency Lowering (Models 71xx & 88xx)
Test Emergency Lowering (Model 9250)
Test Steering
AC Outlet on Platform
Platform Control Console
Powered Extension Control Console (If Equipped)
Test Emergency Powered Extension Platform Retraction Switch
(Model 9250)
Base Control Console
Lanyard Attachment Anchors
Engine Oil Level
Hydraulic Pump
Engine Air Filter
Engine Compartment
Platform Assembly
Hydraulic Tank (Models 71xx & 88xx)
Engine Control Console
Radiator
Muffler and Exhaust
Fuel Leaks
Fuel Tank
Fuel Leaks
Engine Tray
Manifolds
Lifting Mechanism
Base
Hydraulic Oil (Models 71xx & 88xx)
Emergency Lowering Access Rod (All Models Except 9250)
Wheel/Tire Assembly
Hydraulic/Fuel Compartment
Electrical Panel
Load/Tilt Sensor
Hydraulic Tank (Model 9250)
OPERATOR'S CHECKLIS
T
Each item shall be inspected using the appropriate section of the Skyjack operating manual.
DAIL
Y
- FAIL
FREQUENTL
Y
- REPAIRED
A
NNUALL
Y
- NOT APPLICABLE
- PASS
Visual and Daily Maintenance Inspections
Labels
Electrical
Limit Switches
Base Control Switches
Battery
Serial Number:
Model:
Hourmeter Reading: Operator's Name (Printed):
Date:
Time: Operator's Signature:
A
s each item is inspected, check the appropriate box.
Hydraulic Oil
Scissor Bumpers
Lift Cylinder(s)
BI-ANNUALL
Y
Hydraulic/Electrical Compartment
Hydraulic
Main Power Disconnect Switch
Scissor Guards
Sliders
Maintenance Support
Scissor Assembly
Base Weldment
Manuals
Test Speed Limit
Drive Axle
Platform Control Console
Test Horn
Test Emergency Stop
Test Platform Raising/Lowering
Test Enable Trigger Switch
Test Extension Platform(s) (If Equipped)
Steer Cylinder Assembly
Ladder
Outriggers (If Equipped)
Test Lowering Warning
Tie Rod
Test Brake
Test Driving
Test Lift Enable
Test Powerdeck Enable (If Equipped)
Note:
Make a copy of this page or visit the Skyjack web site:
www.skyjack.com
for a printable copy.



