Skyjack SJ40T User Manual

It is the responsibility of the operator to read, completely understand and follow all instructions and warnings
contained in this operating manual and on the aerial platform.
FAMILIARIZATION
2.3-5 Engine Compartment
- Ensure all compartment latches are secure
and in proper working order.
• Main Power Disconnect Switch
(see right side for 61T/66T)
- Turn main power disconnect switch to
“ ” off position.
- Ensure there are no loose or missing
parts and there is no visible damage.
- Ensure all cables are secure and switch
is in proper working condition.
• Battery
Proper battery condition is essential to good
engine performance and operational safety.
Improper uid levels or damaged cables and
connections can result in engine component
damage and hazardous conditions.
WARNING
Explosion hazard. Keep ames
and sparks away. Do not smoke
near batteries.
WARNING
Battery acid is extremely corrosive -
Wear proper eye and facial protection as
well as appropriate protective clothing.
If contact occurs, immediately ush with
cold water and seek medical attention.
1. Check battery case for damage.
2. Clean battery terminals and cable ends
thoroughly with a terminal cleaning tool or
wire brush.
3. Ensure all battery connections are tight.
4. If applicable, check battery uid level. If plates
are not covered by at least 1/2” (13 mm) of
solution, add distilled or demineralized water.
5. Replace battery if damaged or incapable of
holding a lasting charge.
WARNING
Use original or manufacturer-approved
parts and components for the aerial
platform.
• Swing Drive Motor
- Ensure there are no loose or missing
parts and there is no visible damage.
- Ensure all bolts are properly tightened.
- Ensure all ttings and hoses are properly
tightened and there is no evidence of
hydraulic leakage.
Main Power Disconnect Switch
Swing Drive Motor
Battery
High Pressure
Filter
Hydraulic
Pumps
Mufer
Engine
Air Filter
Typical SJ 40T/45T shown
(for model 61T/66T, see note below)
Page 22
SJ 40T & SJ 45T
SJ 61T & SJ 66T
Visual & Maintenance Inspection Section 2 - Familiarization

Skyjack SJ40T Specifications

General

Brand	Skyjack
Model	SJ40T
Category	Boom Lifts
Language	English