Sony HCDSHAKEX70 - User Manual

SERVICE MANUAL
Sony Corporation
Published by Sony EMCS (Malaysia) PG Tec
CD/DVD RECEIVER
9-890-688-04
2019J80-1
©
2019.10
US Model
Canadian Model
HCD-SHAKE10/SHAKE30
AEP Model
Thai Model
HCDSHAKEX30/HCDSHAKEX70
UK Model
HCDSHAKEX30
Russian Model
Australian Model
HCDSHAKEX10/HCDSHAKEX30
E Model
HCDSHAKEX10/
HCDSHAKEX30/
HCDSHAKEX70
Ver. 1.3 2019.10
• HCD-SHAKE10 is the tuner, USB, CD Player, Bluetooth, NFC and amplifi er section in SHAKE-X10.
• HCD-SHAKE30 is the tuner, USB, CD Player, Bluetooth, NFC and amplifi er section in SHAKE-X30.
• HCDSHAKEX10 is the tuner, USB, DVD Player, Bluetooth, NFC and amplifi er section in SHAKE-X10D.
• HCDSHAKEX30 is the tuner, USB, DVD Player, Bluetooth, NFC and amplifi er section in SHAKE-X30D.
• HCDSHAKEX70 is the tuner, USB, DVD Player, Bluetooth, NFC and amplifi er section in SHAKE-X70D.
SPECIFICATIONS
CD/DVD Section
Model Name Using Similar Mechanism HCD-SHAKEX1/SHAKEX3/SHAKEX7
CD/DVD Mechanism Type CDM90-DVBU204//M
Optical Pick-up Name CMS-S76RFS7GP
Photo: HCDSHAKEX70
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION:
(US models only)
Shake-X30 only
With 4 ohm loads, both channels driven, from
150 Hz – 20,000 Hz; rated 90 watts per channel
minimum RMS power, with no more than 0.7%
total harmonic distortion from 250 milliwatts to
rated output.
Shake-X10 only
With 4 ohm loads, both channels driven, from
150 Hz – 20,000 Hz; rated 80 watts per channel
minimum RMS power, with no more than 0.7%
total harmonic distortion from 250 milliwatts to
rated output.
Inputs
AUDIO/PARTY CHAIN IN L/R
(SHAKE-X10/X30):
Voltage 2 V, impedance
47 kilohms
AUDIO/PARTY CHAIN IN (TV) L/R
(SHAKE-X10D/X30D/X70D):
Voltage 2 V, impedance
47 kilohms
TV (ARC) (SHAKE-X10D/X30D/X70D):
Supported audio signal:
2-channel Linear PCM
MIC1:
Sensitivity 1 mV, impedance
10 kilohms
MIC2/GUITAR:
Sensitivity 1 mV, impedance
10 kilohms (When guitar mode is
turned off.)
Sensitivity 200 mV, impedance
1 Megaohm (When guitar mode is
turned on.)
Outputs
AUDIO/PARTY CHAIN OUT L/R:
Voltage 2 V, impedance 1 kilohm
VIDEO OUT (SHAKE-X10D/X30D/X70D):
Max. output level 1 Vp-p,
unbalanced, Sync. negative load
impedance 75 ohms
HDMI OUT (TV) (SHAKE-X10D/X30D/
X70D):
Supported audio signal:
2-channel Linear PCM (up to
48 kHz), Dolby Digital
HDMI section (SHAKE-X10D/X30D/X70D)
Connector:
Type A (19 pin)
Disc player section
System:
Compact disc and digital audio system
(SHAKE-X10/X30)
Compact disc and digital audio and
video system (SHAKE-X10D/X30D/
X70D)
Laser Diode Properties
Emission Duration: Continuous
Laser Output*: Less than 44.6 μW
* This output is the value measurement
at a distance of 200 mm from the
objective lens surface on the Optical
Pick-up Block with 7 mm aperture.
Frequency response:
20 Hz – 20 kHz
Video color system format (SHAKE-X10D/
X30D/X70D):
LA9 model:
NTSC
Other models:
NTSC and PAL
USB section
Supported USB device:
Mass Storage Class
Maximum current:
1 A
(USB) port:
Type A
FM tuner section
FM stereo, FM superheterodyne tuner
Antenna:
FM lead antenna
Tuning range:
87.5 MHz – 108.0 MHz (100 kHz step)
(SHAKE-X10/X30)
87.5 MHz – 108.0 MHz (50 kHz step)
(SHAKE-X10D/X30D/X70D)
BLUETOOTH section
Communication system:
BLUETOOTH Standard version 3.0
Output:
BLUETOOTH Standard Power Class 2
Maximum communication range:
Line of sight approx. 10 m (33 ft)
*1
Frequency band:
2.4 GHz band (2.4000 GHz –
2.4835 GHz)
Modulation method:
FHSS (Freq Hopping Spread Spectrum)
Compatible BLUETOOTH profiles
*2
:
A2DP (Advanced Audio Distribution
Profile)
AVRCP (Audio Video Remote Control
Profile)
SPP (Serial Port Profile)
Supported codecs:
SBC (Subband Codec)
AAC (Advanced Audio Coding)
LDAC
*1
The actual range will vary depending on
factors such as obstacles between devices,
magnetic fields around a microwave oven,
static electricity, reception sensitivity,
antenna’s performance, operating system,
software application, etc.
*2
BLUETOOTH standard profiles indicate the
purpose of BLUETOOTH communication
between devices.
– Continued on next page –
HCD-SHAKE10/SHAKE30/
HCDSHAKEX10/HCDSHAKEX30/HCDSHAKEX70
Note:
Be sure to keep your PC used for service and
checking of this unit always updated with the
latest version of your anti-virus software.
In case a virus aff ected unit was found during
service, contact your Service Headquarters.
SYSSET
2019/10/2523:34:43(GMT+09:00)

Summary

Servicing Notes and Model Identification

Notes on Optical Pick-up and Laser Diode Handling

Safety and handling guidelines for optical pick-up and laser diode checks.

Model Identification

Lists different models and their corresponding part numbers for identification.

Disassembly Procedures

Disassembly Flow

Step-by-step guide for disassembling the unit in the correct order.

Panel, Side, and Top Panel Removal

Instructions for removing the side and top panels of the unit.

CD;DVD Mechanism Disassembly

Detailed steps for removing the CD/DVD mechanism (CDM90-DVBU204//M).

Motherboard Board Disassembly

Procedure for disassembling the main motherboard.

Test Modes and Diagnostics

System Test Modes

Modes for checking panel, version, model, and performing resets.

Electrical Check Procedures

Procedures for checking tuner and focus bias for electrical diagnostics.

Circuit Diagrams and Board Layouts

Circuit Board Locations

Visual guide showing the placement of various circuit boards within the unit.

Amp Section Block Diagram

Block diagram detailing the audio amplifier section's components and connections.

Motherboard Board Printed Wiring Board

Component layout view of the motherboard (component side).

Mic Board Schematic Diagram

Detailed schematic diagram for the microphone input board.

Exploded Views

Panel, Side Section Exploded View

Exploded view showing the removal of side panels and related parts.

Back Panel Section Exploded View

Exploded view illustrating the disassembly of the back panel.

Motherboard Board Section Exploded View

Exploded view showing the motherboard and its related components.

CD;DVD Mechanism Section Exploded View

Exploded view of the CD/DVD mechanism and associated parts.

Electrical Parts List

Semiconductors and Passive Components

Lists of semiconductors, resistors, capacitors, and coils with part details.

Connectors, Switches, and Jumpers List

Lists of connectors, tactile switches, and jumper resistors with part details.

Sony HCDSHAKEX70 Specifications

General

Brand	Sony
Model	HCDSHAKEX70
Speaker Type	2-Way
Bluetooth	Yes
USB Playback	Yes
FM Radio	Yes
NFC	Yes
CD Player	Yes
DVD Player	No
Equalizer	Yes
Bass Boost Function	Yes
Radio	FM
Functions	CD, USB, Bluetooth, FM Radio
Audio Input	3.5mm Aux In