16
To maintain the station with full efficiency it is necessary to perform regular maintenances.
The disrespect of performing the maintenances from the customers side frees the producer
From every responsibility concerning the guarantee.
All maintenance works have to be performed after the separation of the station from the net. Replace the drier
filter and the oil of the pump regularly (according to the use) and clean the de-oiling filter as well. The display
will then show the message „Attention 9“, for the performance of the maintenance of the station after 150
hours of functioning of the compressor.
Pump oil
Replace the pump oil every 100/150 hours of functioning or at least every 2 years even when the station is not
continuously in use. The exchange of oil is absolutely necessary even when the presence of polluting
substances can cause cloudiness, in this
case this can cause irreversible damages on the mechanical parts of the
pump. Use only mineral oil for vacuum pumps type AV68I.
The amount is approx. 300 gram.
Oil refill
1) Fill the new oil into the cap “b”, until you reach the height of the appropriate glass.
Exchange of pump oil
1) Discharge the oil from the cap “a”.
2) Insert the new oil via the cap “b”, until you reach the height of the appropriate visualizing glass “c”.
Attention: Do not dispose of the oil via normal waste but via special waste according to the law. Cod. Oil
exchange: AV68I
CHAP. 7 REGULAR MAINTENANCE
To Next Page
Loading...