Sullair TS-32S - Page 100

To Next Page

To Previous Page

Section 8

ILLUSTRATIONS AND PARTS LIST

8.14 AIR PIPING SYSTEM- WATER-COOLED 500-600HP/ 373-447KW

02250137-341R03

Main Page

Table of Contents3
General7
Personal Protective Equipment7
Pressure Release7
Fire and Explosion8
Hot Surfaces, Sharp Edges and Sharp Corners8
Moving Parts8
Electrical Shock9
Lifting9
Toxic and Irritating Substances9
Entrapment10
Description of Components11
Introduction11
Compressor Cooling and Lubrication System, Functional Description12
Sullair Compressor Unit, Functional Description12
Compressor Discharge System, Functional Description14
Control System, Functional Description14
Air Inlet System, Functional Description24
Lubrication Guide- Standard Compressors25
Sullair Series Ts-32S Specifications25
Application Guide26
Lubrication Change Recommendations and Maintenance26
Lubrication Guide- 24Kt Compressors26
Coupling Alignment Check41
Fluid Level Check41
Mounting of Compressor41
Service Air Piping41
Ventilation and Cooling41
Fluid Piping (Remote Air-Cooled Option Only)42
Electrical Preparation43
Motor Rotation Direction Check43
Supervisor Control Panel44
Introduction45
Purpose of Controls45
Initial Start-Up Procedure46
Shutdown Procedure47
Subsequent Start-Up Procedure47
Daily Operation49
Fluid Change49
General49
Maintenance after 1000 Hours49
Maintenance after Initial 50 Hours of Operation49
Parts Replacement and Adjustment Procedures49
- Main Filter Maintenance49
  - Troubleshooting Guide57
  - Procedure for Ordering Parts61
- Recommended Spare Parts List62
- Motor, Compressor, Frame and Parts- Gear Drive64
- Motor, Compressor, Frame and Parts- Direct Drive71
- Air Inlet System72
- Fluid Cooling System- Air-Cooled 400Hp/ 298Kw74
- Fluid Cooling System- Air-Cooled 500-600Hp/ 373-447Kw78
- Horizontal Remote Cooler- 600Hp/ 447Kw82
- Fluid Cooling System- Water-Cooled 400Hp/ 298Kw84
- Fluid Cooling System- Water-Cooled 500-600Hp/ 373-447Kw86
- Air Piping System- Air-Cooled 400Hp/ 298Kw90
- Air Piping System- Air-Cooled and Remote-Cooled 500-600Hp/ 373-447Kw92
- Air Piping System- Water-Cooled 400Hp/ 298Kw96
- Air Piping System- Water-Cooled 500-600Hp/ 373-447Kw98
- Fluid Piping System- Air-Cooled 400Hp/ 298Kw102
- Fluid Piping System- Air-Cooled 500-600Hp/ 373-447Kw104
Separator Maintenance49
Fluid Piping System- Water-Cooled 400Hp/ 298Kw106
Fluid Piping System- Water-Cooled 500-600Hp/ 373-447Kw108
Fluid Piping System- Remote-Cooled 500-600Hp/ 373-447Kw110
Sump and Parts114
- Sullicon Control118
- Compressor Spiral Valve Actuator120
- A Moisture Drain- 400Hp/ 298Kw122
- B Moisture Drain 500-600Hp/ 373-447Kw122
- Pneumatic Controls124
Control Box- Solid State (Typical)130
Control Box- Full Voltage (Typical)132
Control Box- Wye-Delta (Typical)134
Insulation- Air-Cooled 400-600Hp/ 298-447Kw136
Insulation- Water-Cooled and Remote-Cooled 400-600Hp/ 298-447Kw138
Enclosure- Air-Cooled140
Enclosure- Water-Cooled144
Decals148
Decal Locations154
Decal Locations- Air-Cooled Enclosure156
Decal Locations- Water-Cooled Enclosure158
Decal Locations- Control Box160
Decal Locations- After-Cooler162
Wiring Diagram- Air-Cooled/Full Voltage164
Wiring Diagram- Water-Cooled/Full Voltage165
Wiring Diagram- Air-Cooled/Wye-Delta166
Wiring Diagram- Water-Cooled/Wye-Delta167
Wiring Diagram- Air-Cooled/Solid State168
Wiring Diagram- Water-Cooled/Solid State169
Wiring Diagram- Air-Cooled/Remote-Cooler170

Sullair TS-32S - Page 100

Table of Contents

Related product manuals