10. Inspection and maintenance before riding
14
(Please refer to the components location diagram for the following components.)
ROUTINE INSPECTION
Check Items Check Key Points
Engine Oil Is there enough engine oil?
Fuel Is it enough? Is it Octane 90 or above
Front Braking condition? (Brake lever free play: 10~20mm)
Brake
Rear Braking condition? (Brake lever free play: 10~20mm)
Front
Is tire pressure normal?
(Standard: 1.75kg/cm
2
)
Tires
Rear
Is tire pressure normal?
(Standard: 2.0 kg/cm
2
for 1 person, 2.25 kg/cm
2
for 2 persons)
Steering Handle Does the handle vibrate abnormally or is difficult to turn?
Speedometer, lights,
and rearview mirror
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Tightness of Main Components
Are screws, nuts loosen?
Abnormal Points Do the previous troubles still exist?
CAUTION:
If any problems are found during routine inspections always correct them before riding the scooter. If
necessary, have the scooter inspected and repaired by an Authorized SANYANG dealer.
ENGINE OIL INSPECTION AND CHANGE
INSPECTION:
1. Use the main parking stand to support the motorcycle on a level ground, remove the dipstick after
engine stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do
not rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase…etc for leakage.)
OIL CHANGE:
Change engine oil after the first 300km, and change the
engine oil every 3,000km thereafter. Clean oil filter after
the first 300km, and clean oil filter every 6,000km.
In order to maintain the engine’s maximum performance,
check whether the engine oil is enough every 1,000km.
Add oil to upper limit if the engine oil has been found to
be inadequate.
Engine Oil : Use API SH, SAE 10w-40 grade or better
engine oil. Otherwise, damage will not be covered by
warranty.
※ Recommended Oil: SYM Genuine EXTRA 4X OIL.
Oil Capacity : 1.4 Liter (1.2 liters for routine change),
oil filter change: 1.2 liters.
To Next Page
Loading...
Need help?
General
