Sym JOYRIDE 150

14
10. INSPECTION AND MAINTENANCE BEFORE RIDING
(Please refer to the components location diagram for the following components.)
ROUTINE INSPECTION
Check Items Check Ke
y
Points
En
g
ine Oil Is there enou
g
h en
g
ine oil?
Fuel Is it enou
g
h? Is it Octane 90 or above
Front
Braking condition?
(Brake lever free play: 10~20mm)
Brake
Rear
Braking condition?
(Brake lever free play: 10~20mm)
Front
Is tire pressure normal?
(Standard: 1.75kg/cm
2
)
Tires
Rear
Is tire pressure normal?
(Standard: 2.25 kg/cm
2
for 1 person, 2.5 kg/cm
2
for 2 persons)
Steerin
g
Handle Does the handle vibrate abnormall
y
or is difficult to turn?
Speedometer, lights,
and rearview mirror
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Ti
g
htness of Main Com
p
onents Are screws
,
nuts loosen?
Abnormal Points Do the
p
revious troubles still exist?
ENGINE OIL INSPECTION AND CHANGE
INSPECTION:
1. Use the main parking stand to support the motorcycle on a level ground, remove the dipstick after
engine stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do
not rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase…etc for leakage.)
OIL CHANGE:
• Change engine oil after the first 300km, and change the
engine oil every 1000km thereafter. Clean oil filter after
the first 300km, and clean oil filter every 6,000km.
• In order to maintain the engine’s maximum
performance, check whether the engine oil is enough
every 500km. Add oil to upper limit if the engine oil
has been found to be inadequate.
• Engine Oil : Use API SH, SAE 10w-30 grade or better
engine oil. Otherwise, damage will not be covered by
warranty.
※ Recommended Oil: SYM Genuine EXTRA 4X OIL.
• Oil Capacity : 1.0 Liter (0.8 liters for routine change),
oil filter change: 0.8 liters.
CAUTION:
• If any problem founded during routine inspection, correct the problem before using the motorcycle
again, have your motorcycle checked and repaired by the “SYM dealer or authorized service
personnel” if necessary.
Upper limit
Lower limit