Thermo King SLXi-DRC - User Manual

112 pages

Save Page as PDF

To Next Page

Revision B

June 2021

TTKK 5566440022--22--OOPP--EENN

SLXi-DRC

Single Temperature Units

Operator’s Manual

Main Page

Table of Contents4
Danger, Warning, Caution, and Notice9
General Safety Practices9
Automatic Start/Stop Operation10
Battery Installation and Cable Routing10
Refrigerant11
Refrigerant Oil12
First Aid13
Safety Decals and Locations15
Operation15
Remote Start of the Unit16
Refrigerant16
Do Not Use Ether Starting Aids17
Diesel Engine18
Extended Life Coolant (ELC)18
Emi 300019
Thermo King Reciprocating Compressor19
Electronic Throttling Valve20
SMART REEFER 3 (SR-3) Control System20
Continuous Run Operation21
CYCLE-SENTRY™ Start-Stop Controls21
Tracking® Connectedsuite21
Further Communication Capabilities22
Optiset™ Plus22
Freshset23
Defrost23
Engine Compartment23
Unit Protection Devices24
SMART REEFER 3 (SR-3) Controller Overview28
Switching "ON" the Unit28
Microprocessor ON/OFF Switch29
HMI Control Panel29
Control Panel Display29
Control Panel Keys30
Turning Unit on31
If a Language Is Enabled32
Turning the Unit off34
Standard Display35
Standard Display Variations35
Temperature Watch Display36
Alarm Display37
Starting the Diesel Engine38
Unit Fails to Start38
After Start Inspection38
Changing the Setpoint39
Numerical Setpoints39
Named Products - Optiset Plus40
Both Numerical Setpoints and Named Products40
Changing the Setpoint - Numerical Setpoint41
Changing the Setpoint - Named Product44
Changing the Setpoint - both Numerical Setpoint and Named Product Available47
Selection of Operating Modes48
Selecting Cycle Sentry or Continuous Mode49
Initiating a Manual Defrost Cycle51
Terminating a Defrost Cycle52
Using the Gauges Key52
Gauges Available53
Using the Sensors Key54
Sensors Available55
Using the Main Menu56
Main Menu Choices57
Language Menu57
Alarms Menu61
Important Alarm Notes63
Datalogger Menu64
Initiating a Start of Trip64
Printing a Trip Report65
Hourmeters Menu66
Mode Menu68
Turn Cycle Sentry on or off69
Select Temperature Units70
Keypad Lockout71
Start Sleep Mode71
Pretrip72
Pretrip Test Conditions72
Conditions Where Pretrip Tests Are Not Allowed72
Pretrip Test Considerations73
Pretrip Test Sequence73
Performing a Pretrip Test73
Adjust Brightness77
Time78
Introduction80
Alarm Types80
Log Alarm80
Check Alarm81
Prevent Alarm81
Shutdown Alarm82
Pretrip Alarms83
Low Battery Voltage83
Alarm Codes When Switching between Diesel and Electric83
Clearing Alarm Codes83
Pre-Loading Inspection93
Post-Loading Inspection94
Enroute Inspections95
Inspection Procedure95
Inspection Troubleshooting95
J J U U M M P P S S T T a a R R T T I I N N G99
Engine102
Refrigeration System103
Electrical Control System103
Tracking® Connectedsuite103
M M a a I I N N T T E E N N a a N N C C E E I I N N S S P P E E C C T T I I O O N N S S C C H H E E D D U U L L E106
EPA and ARB Supplemental Emissions Warranty110
Statement110

Brand	Thermo King
Model	SLXi-DRC
Category	Air Conditioner
Language	English

Thermo King SLXi-DRC - User Manual

Table of Contents

Thermo King SLXi-DRC Specifications

Related product manuals