Make sure that there are no loose objects under the hood that might damage or
interfere with the pedals or battery.
Check that the battery is connected and tightened firmly in its place. Make sure
that there are no metal parts that could short the battery.
Top up the washer fluid if necessary.
Make sure that the hood is secured onto the car with the rubber straps.
Check that the harness is secured correctly and is in good condition.
Engage the parking brake and check that the vehicle does not roll.
Check for large oil leaks from the transmission box and final drive. Slight oil
moisture is not problematic. Vehicle operation can result in oil drips from the
breathers.
Check shock absorbers by pressing the vehicle hard downward. The vehicle
should spring back slowly and symmetrically.
Check that all fasteners are in place and tight.
If carrying a heavy payload that effects the ground clearance, fill the load
compensators with compressed air at 150 psi.
Rear Transmission Drive
Belt
Check driving belt for wear and tear. Check the belt’s tension.
Electric drive components
Check visible orange cables for wear and tear.
Check traction battery box for any visible damage.
After vehicle start up make sure the motor controller cooling fan is ON visually.
To Next Page
Loading...