Toro Recycler 20070 - User Manual

22in Recycler ® Lawn Mower
Form No. 3354-915 Rev A
Model No. 20070--Serial No. 260000001 and Up
Operator's Manual
Introduction
Read tlfls information carefiflh to learn how to operate and
maintain xour, product properl) and to avoid in}ur) and
product damage. X*%uare responsible for operating the
product properl) and safeh<
X*%umax contact Toro directl) at wwxx:Toro.com for
product and accessor) information, help finding a dealer,
or to register ?our product.
\'(henever xou, need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model and
serial nmnbers of your product read?: Figure 1 identifies the
location of the model and serial numbers on the product.
Figure 1
1.
.3002873
Model and serial number plate
\'('rite the product model and serial numbers in the space
below:
I Model No.
Serial No.
This manual identifies potential hazards and has safety
messages identified b_ the safety" alert swnbol (Figure 2),
wlflch signals a hazard that may cause serious in}ury or
death if _ou do not follow the recommended precautions.
Figure 2
I. Safety alert symbol
This manual uses taro words to lflghlight information.
Important calls attention to special mechaaical information
and Note emphasizes general information worthy of special
attention.
CALIFORNIA
Proposition 65 Warning
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
Important: This engine is not equipped with a
spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate
the engine on any forest-covered, brush-covered, or
grass-covered land. Other states or federal areas may
have similar laws.
This spark igaition sxstem complies with Canadian
ICES-002
The enclosed Engine Owner's Manual is supplied
for information regarding the US Environmental
Protection Agency (EPA) and the California Emission
Control Regulation of emission systems, maintenance,
and warranty. Replacements may be ordered through
the engine manufacturer.
For models with stated engine horsepower, the gross
horsepower of the engine was laborator? rated b? the engine
manufacturer in accordance with SAt j 1940. As configured
to meet safet3; emission, and operating requirements, the
actual e_gine horsepower on this class of lawn mower will
be significantly lower.
Safety
This lawn mower meets or exceeds the CPSC blade safet)
requirements for walk-belflnd rotar_ lawn mowers and the
B71.1 specifications of the American National Standards
Institute in effect at the time of production.
Read and understand the contents of this manual
before you start the engine.
The safet_ alert swnbol (Figure 2) is used to alert you to
potential personal in}ur) hazards. Obe) all safety messages
that follow this swnbol to avoid possible in}ur) or death.
Improperl) using or maintaining this mower could resuh in
in}ury or death. To reduce this potential, comply with the
following safety" instructions.
®
© 2005--The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420
Register at www.Toro.com. Original Instructions (EN)
Printed in the USA.
All Rights Reserved

Summary

Safety Guidelines

General Mower Safety

Overarching safety instructions to prevent injury and property damage during operation.

Operation Guidelines

General Operation Rules

Essential instructions for safe and proper operation of the lawn mower.

Slope Operation Safety

Specific safety precautions for operating the mower on inclines.

Child Safety Measures

Critical steps to ensure children's safety around the mower.

Fuel Handling Safety

Gasoline Safety Precautions

Guidelines for safe handling and storage of gasoline to prevent fire and explosion.

Safety Labels and Warnings

Battery Charging Safety

Operational Safety Warnings

Discharge Control Safety

Setup Procedures

Engine Oil Filling

Step-by-step guide for adding the correct amount of oil to the engine.

Mower Operation

Fueling the Tank Safely

Essential safety measures and steps for filling the fuel tank.

Engine Oil Level Check

Detailed instructions for checking and maintaining the engine oil level.

Engine Starting

Initial Engine Start

Procedure for priming and starting the mower engine.

Engine Operation

Starting the Engine

Instructions for starting the engine using recoil or electric starter.

Stopping the Engine

Method for safely stopping the engine and safety checks.

Mowing Attachments

Mowing Techniques

General Mowing Tips

Cutting Grass Best Practices

Maintenance Schedule and Procedures

Recommended Maintenance Intervals

A schedule detailing maintenance tasks based on usage hours.

Pre-Maintenance Safety Steps

Air Filter Replacement

Engine and Battery Maintenance

Engine Oil Change

Detailed steps for draining and refilling the engine oil.

Battery Charging Guide

Fuse Replacement Procedure

Blade and Mower Care

Blade Replacement

Procedure for safely replacing the mower blade, including torque specifications.

Mower Storage Preparation

Storage and Retrieval

Off-Season Storage Instructions

Comprehensive guide for preparing and storing the mower during the off-season.

Toro Recycler 20070 Specifications

General

Engine Displacement	140 cc
Drive Type	Self-Propelled
Deck Material	Steel
Mulching Capability	Yes
Bagging Capability	Yes
Side Discharge Capability	Yes
Engine	Briggs & Stratton
Cutting Width	22 in
Cutting Height	1.25 - 3.75 in
Starting System	Recoil
Cutting Height Adjustment	Single Lever
Starter Type	Recoil