Toro Recycler Series User Manual

22in Recycler Lawn Mower
Form No. 3360-862 Rev B
Model No. 20332mSerial No. 290000001 and Up
Model No. 20332CmSerial No. 290000001 and Up
Model No. 20334--Serial No. 290000001 and Up
Model No. 20334C--Serial No. 290000001 and Up
Model No. 20352--Serial No. 290000001 and Up
Operator's Manual
Replacement parts are available from an Authorized Service Dealer or at www.shoptoro.com.
Introduction
Read this information carefully to learn how to operate
and maintain your product properly and to avoid injury
and product damage. You are responsible for operating
the product properly and safely.
You may contact Toro directly at v_,w,vToro.com for
product and accessory information, help finding a
dealer, or to register your product.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model
and serial numbers of your product read> Figure 1
identifies the location of the model and serial numbers
on the product.
f -_ " 1
Figure 1
1. Model and serial number plate
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has
safeff messages identified by the safe_ _alert symbol
(Figure 2), which signals a hazard that may cause serious
injury or death if you do not follow the recommended
precautions.
Figure 2
1. Safety alert symbol
This manual uses 2 words to highlight information.
Important calls attention to special mechanical
information and Note emphasizes general information
worthy of special attention.
CALIFORNIA
Proposition 65 Warning
The engine exhaust from this product
contains chemicals known to the State of
California to cause cancer, birth defects,
or other reproductive harm.
Important: This engine is not equipped with a
spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate
the engine on any forest-covered, brush-covered, or
grass-covered land. Other states or federal areas
may have similar laws.
This spark ignition system complies vdth Canadian
ICES-002.
The enclosed Engine Owner's Manual is supplied
for information regarding the US Environmental
Protection Agency (EPA) and the California
Emission Control Regulation of emission systems,
© 2008--The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
Register at www.Toro.com. Original Instructions (EN)
Printed in the USA
All Rights Reserved

Toro Recycler Series Specifications

General

Deck Material	Steel
Mulching Capability	Yes
Bagging Capability	Yes
Side Discharge	Yes
Start Type	Recoil or Electric Start (varies by model)
Engine	Briggs & Stratton or Toro
Cutting Width	22 inches
Cutting Height Adjustment	Single Lever

Summary

Introduction and Safety Information

Safety Alert Symbol Explained

Explains the meaning and purpose of the safety alert symbol.

Manual Highlighting Terms

Defines 'Important' and 'Note' for highlighting key information.

Safety Precautions and General Operation

General Safety Rules

Lists essential safety rules for operating the lawn mower.

Slope Operation Safety

Provides guidance for safely mowing on slopes and inclines.

Child Safety and Service Guidelines

Child Safety

Emphasizes precautions to keep children safe from the mower.

Safe Gasoline Handling

Critical safety instructions for handling flammable gasoline.

General Service Procedures

Outlines general maintenance and safety checks for the mower.

Safety and Instructional Decals

Manufacturer's Mark Decal

Indicates the blade is an original machine part.

DANGER/PELIGRO Warning Decal

Prominent hazard warning for hands and feet.

Battery Charging Instructions Decal

Provides guidelines for charging the battery.

Operator's Manual Reference Decal

Instructs users to read the operator's manual.

Lock/Unlock Mechanism Decal

Indicates the function of a lock and unlock mechanism.

Multiple Safety Warnings Decal

Contains several safety warnings and operating instructions.

Initial Setup Procedures

Installing the Handle

Step-by-step guide to installing the mower handle.

Filling the Engine with Oil

Procedure for adding the correct amount of engine oil.

Installing the Fuse

Instructions for installing the fuse for electric-start models.

Battery Charging

Charging the Battery

Procedure and notes for charging the mower's battery.

Product Overview and Fueling

Mower Components Identification

Diagram identifying key parts of the lawn mower.

Mower Accessories Identification

Diagram identifying mower accessories like grass bag.

Filling the Fuel Tank

Instructions and precautions for filling the fuel tank.

Engine Oil and Cutting Height Adjustment

Checking Engine Oil Level

Procedure for checking and maintaining the engine oil level.

Adjusting Cutting Height

Instructions on how to adjust the cutting height of the mower.

Starting and Self-Propel Operation

Starting the Engine

Step-by-step guide for starting the mower's engine.

Using the Self-Propel Drive

How to engage and operate the self-propel feature.

Stopping, Recycling, and Bagging Clippings

Stopping the Engine

Procedure for safely stopping the mower's engine.

Recycling Grass Clippings

Instructions on how to set the mower for mulching clippings.

Bagging Grass Clippings

Guidance on using the grass bag to collect clippings.

Grass Bag Installation and Operation

Installing the Grass Bag

Steps for correctly attaching the grass bag to the mower.

Operating the Bag-on-Demand Lever

How to switch between bagging and recycling modes.

Side Discharge Chute Installation and Use

Installing the Side Discharge Chute

Instructions for attaching the side discharge chute.

Side-Discharging Clippings

Guidance on using the side discharge for tall grass.

Operating Tips for Mowing

General Mowing Best Practices

Advice for efficient and safe mowing.

Cutting Grass Effectively

Tips for optimal grass cutting height and frequency.

Cutting Leaves

Recommendations for mowing leaf-covered lawns.

Maintenance Schedule and Preparation

Recommended Maintenance Schedule

A schedule outlining maintenance tasks and intervals.

Preparing for Maintenance

Essential steps to take before performing maintenance.

Filter Replacement and Oil Change

Replacing the Air Filter

Procedure for replacing the mower's air filter.

Changing the Engine Oil

Step-by-step instructions for changing the engine oil.

Battery, Fuse, and Blade Maintenance

Charging the Battery

Instructions for charging the battery for electric-start models.

Replacing the Fuse

Procedure for replacing a blown fuse.

Replacing the Blade

Guidance on inspecting and replacing the mower blade.

Blade Replacement and Cable Adjustment

Blade Removal and Installation

Detailed steps for removing and installing the mower blade.

Adjusting the Self-Propel Drive Cable

Procedure for adjusting the self-propel drive cable.

Mower Cleaning and Storage Preparation

Cleaning the Mower

Instructions for cleaning the mower, including using the washout port.

Preparing Mower for Storage

Steps to prepare the mower for long-term storage.

Handle Folding and Post-Storage Setup

Folding the Handle

Procedure for safely folding the mower's handle.

Removing Mower from Storage

Steps to prepare the mower after it has been stored.

Toro Warranty Information

Toro GTS Starting Guarantee

Warranty coverage for the Toro GTS engine starting.

Items and Conditions Not Covered by Warranty

Lists exclusions from the Toro warranty coverage.

Owner Responsibilities for Warranty

Details the owner's responsibilities for maintaining warranty coverage.

Obtaining Warranty Service

Instructions on how to get service under warranty.