Toyota 4A-FE - Troubleshooting

Fl-14
EFI SYSTEM - Troubleshooting
FI0402
TROUBLESHOOTING
TROUBLESHOOTING HINTS
1. Engine trouble are usually not caused by the EFI system.
When troubleshooting, always firstly check the condition
of the other systems.
(a) Electronic source
• Battery
• Fusible links
• Fuses
(b) Body ground
(c) Fuel supply
• Fuel leakage
• Fuel
filter
•Fuel pump
(d) Ignition system
• Spark plugs
•
High-tension cords
• llA or Distributor
• Ignition coil
• Igniter
(e) Air induction system
•
Vacuum leaks
(f) Emission control system
• PCV
system
• EGR system (w/ EGR system)
(g) Others
• Ignition timing
• Idle speed
• etc.
2. The
most frequent cause of problems is simply a bad con-
tact in wiring connectors. Always check that connections
are secure.
When inspecting the connector, pay particular attention to
the following points:
{a) Check to see that the terminals are not bent.
(b) Check to see that the connector is pushed in com-
pletely and locked.
(c) Check to see that there is no signal change when the
connector is slightly tapped or wiggled. ·
3.
Sufficiently troubleshooting for other causes before rep-
lacing
the ECU, as the ECU is high quality and expensive.