Tracker Off-Road 600 - Battery

57
 NOTE: Take the ATV to an autho-
rized dealer for this service.
Gas Hoses
Inspect the gas hoses. Damage from
aging may not always be visible.
Protective Rubber
Boots
The protective boots should be inspected
periodically according to the Mainte-
nance Schedule.
Ball Joint Boots (Upper
and Lower/Right and Left)
XR486A
XR487A
1. Secure the ATV on a support stand to
elevate the front wheels.
2. Remove both front wheels.
3. Inspect the four ball joint boots for
cracks, tears, or perforations.
4. Check the ball joint for free-play by
grasping the steering knuckle and
turning it from side to side and up and
down.
5. If boot damage is present or ball joint
free-play seems excessive, contact an
authorized dealer for service.
Tie Rod Boots (Inner and
Outer/Right and Left)
OHA033
1. Secure the ATV on a support stand to
elevate the front wheels.
2. Remove both front wheels.
3. Inspect the four tie rod boots for
cracks, tears, or perforations.
4. Check the tie rod end free-play by
grasping the tie rod near the end and
attempting to move it up and down.
5. If boot damage is present or tie rod
end free-play seems excessive, con-
tact an authorized dealer for service.
Drive Axle Boots
OHA032
1. Inspect all drive axle boots for cracks,
tears, or perforations.
2. If boot damage is present, contact an
authorized dealer for service.
Battery
Remove seat and right-side panel to
access battery.