Engine Oil and Oil Filter Cartridge
The Engine oil level should be checked before each operation. In addition, the oil must be changed and
oil filter cartridge replaced at the intervals specified in the periodic maintenance and lubrication chart.
Service Engine Crankcase Oil
You must change the oil in the crankcase after the
first 5 hours of operating of your new engine and
after 10 hours of use thereafter. This will ensure
proper lubrication of the internal parts and prevent
costly repairs due to excessive wear.
1)
Remove the screen cap drain plug located
forward of the engine oil fill plug on the bottom
right side of the engine. Upon removal of the
plug, a filter screen will be visible. Elevating
the front of the vehicle slightly will help drain all
of the oilout.
2)
Emptyalloftheoilintoasuitablecontainer.
3)
Remove and clean the oilscreen
4)
With the oil completely drained, replace the
screenanddrainplug,thentightensecurely.
5)
Replace the vehicle back on a flat surface to
level the engine, and refill the crankcase with30
oz of SAE 10W40 motoroil.
6)
Check the oil level using the dipstick attachedto
the oil plug cap. Be sure to the check oil level
before each use of thevehicle.
7)
Add oil when necessary to keep the oil level
between then bottom of the dipstick and the
“O”mark.
To Next Page
Loading...
