UTICA BOILERS DV - User Manual

USER'S
INFORMATION
MANUAL
P/N 37615901, Rev. B [3/2011]
SERIES DV
GAS FIRED HOT WATER HEATING BOILER
WARNING: If the information in this manual is not
followed exactly, a re or explosion may result causing
property damage, personal injury or loss of life.
Do not store or use gasoline or other ammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.•
Do not touch any electrical switch; do not use •
any phone in your building.
Immediately call your gas supplier from a •
neighbor's phone. Follow the gas supplier's
instructions.
If you cannot reach your gas supplier, call the •
re department.
Installation and service must be performed by a
qualied installer, service agency or the gas
supplier.
Do not use this boiler if any part has been under water. Immediately call a qualied service technician to
inspect the boiler and to replace any part of the control system and any gas control which has been under
water.
Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to
the pump. Instead, shut off the gas supply at a location external to the appliance.
Utica Boilers
2210 Dwyer Avenue, Utica NY 13504-4729
Phone: (315) 797-1310 • Fax: (866) 432-7329
e-mail: info@ecrinternational.com
web site: www.ecrinternational.com

Summary

Safety Symbols and Warnings

DANGER Hazard Identification

Indicates a hazardous situation resulting in death or serious injury if not avoided.

WARNING Hazard Identification

Indicates a hazardous situation resulting in death or serious injury if not avoided.

CAUTION Hazard Identification

Indicates a hazardous situation resulting in minor or moderate injury if not avoided.

NOTICE Information

Provides information to ensure proper installation and operation.

Boiler Lighting Procedures

Intermittent Pilot System Lighting

Step-by-step guide for lighting the boiler with an automatic ignition device.

Gas Leak Checks During Lighting

Procedures for smelling gas before and during the lighting process.

Turning Off Gas Supply

Procedure for safely shutting off the gas supply to the appliance.

General Boiler Maintenance and Inspection

Seasonal Start-up and Checks

Recommendations for annual checks including soot, scale, and gas input rate.

Maintenance Cautions

Warnings regarding wire labeling and over-oiling of components.

Flue Gas Passageway Cleaning

Procedure for cleaning burners, venter assembly, and flue passageways.

Flame Inspection and Safety Switch

Guidance on checking burner flames and understanding the roll-out safety switch.

UTICA BOILERS DV Specifications

General

Brand	UTICA BOILERS
Model	DV
Category	Boiler
Language	English