V2 HYPERFOR 4000-I - Page 36

ENGLISH
- 34 -
AUTOMATION DEVICE
INSTALLERS MANUAL
1 - GENERAL SAFETY INFORMATION
m Prior to proceeding with installation, it is essential the
instructions be read in full, since they contain important
information regarding safety, installation, use and
maintenance.
AUTOMATION MUST BE IMPLEMENTED IN COMPLIANCE WITH
THE EUROPEAN REGULATIONS IN FORCE:
EN 60204-1, EN 12445, EN 12453, EN 13241-1, EN 12635
• Theinstallermustprovideforadevice(es.magnetotermical
switch)ensuringtheomnipolarsectioningoftheequipment
fromthepowersupply.Thestandardsrequireaseparationof
thecontactsofatleast3mmineachpole(EN60335-1).
• TheplasticcasehasanIP44insulation;toconnectexibleor
rigidpipes,usepipettingshavingthesameinsulationlevel.
• Installationrequiresmechanicalandelectricalskills,thereforeit
shallbecarriedoutbyqualiedpersonnelonly,whocanissue
theComplianceCerticateconcerningthewholeinstallation
(MachineDirective2006/42/CEE,AnnexIIA).
• Alsotheautomationupstreamelectricsystemshallcomplywith
thelawsandrulesinforceandbecarriedoutworkmanlike.
• Werecommendtomakeuseofanemergencybutton,tobe
installedbytheautomation(connectedtothecontrolunit
STOPinput)sothatthegatemaybeimmediatelystoppedin
caseofdanger.
• Forcorrectinstallationofthesystem,werecommendfollowing
theinstructionsissuedbyUNACverycarefully.
• Thisinstructionmanualisonlyforqualiedtechnicians,who
specializeininstallationsandautomations.
• Thecontentsofthisinstructionmanualdonotconcerntheend
user.
• Everyprogrammingand/oreverymaintenanceserviceshould
bedoneonlybyqualiedtechnicians.
• Anythingnotexpresslydescribedintheseinstructionsis
prohibited;unforeseenusesmaybeasourceofdangerto
peopleandproperty.
• Donotinstalltheproductinexplosiveenvironmentsand
atmospheres:thepresenceofinammablegasesorfumesisa
serioussafetyhazard.
• Donotmakeanymodicationstoanypartoftheautomation
device,ortheaccessoriesconnectedtoit,unlessdescribedin
thismanual.
• Anyothermodicationswillvoidthewarrantyontheproduct.
• Theinstallationstepsshouldbeconductedsoastoavoidrainy
weather,whichcanexposeelectroniccircuitstodangerous
waterseepage.
• Alloperationsrequiringthecasingofthedevicetoopened
shouldbeperformedwiththecontrolunitdisconnectedfrom
theelectricitysupplyandwithawarningnoticedisplayed,for
example:”CAUTION,MAINTENANCEINPROGRESS”.
• Avoidexposingthedeviceclosetosourcesofheatandame.
• Intheeventofinterventionsonautomaticordifferential
breakersorfuses,itisessentialthatfaultsbeidentiedand
resolvedpriortoresetting.Inthecaseoffaultsthatcannot
beresolvedusingtheinformationtobefoundinthismanual,
consulttheV2customerassistanceservice.
• V2declinesallresponsibilityforfailuretocomplywithgood
constructionpracticestandardsinadditiontostructural
deformationofthegatethatmightoccurduringuse.
• V2reservestherighttomakemodicationstotheproduct
withoutpriorwarning.
• Installation/maintenancepersonnelshouldwearindividual
protectiondevices(IPDs),suchasoveralls,safetyhelmets,boots
andgloves.
• Theambientoperatingtemperatureshouldbethatindicatedin
thetechnicalcharacteristicstable.
• Theautomationdeviceshouldbeshutdownimmediatelyin
theeventofanyanomalousorhazardoussituation;thefault
ormalfunctionshouldbeimmediatelyreportedtotheperson
responsible.
• Allsafetyandhazardwarningsonthemachineryand
equipmentshouldbecompliedwith.
• Electromechanicalactuatorsforgatesarenotintendedtobe
usedbypeople(includingchildren)withdiminishedphysical,
sensoryormentalcapacity,orlackinginexperienceor
knowledge,unlesstheyareundersupervisionorhavebeen
instructedinuseoftheactuatorbyapersonresponsiblefor
safety.
V2 has the right to modify the product without previous
notice; it also declines any responsibility to damage or
injury to people or things caused by improper use or wrong
installation.