Volvo Penta D1 - Page 34

Every 14 days
Drive belts, wear I
Seawater Filter, Check and Cleaning I C
Fuel pre-filter, draining water / contamination I
Batteries, electrolyte level I
Reverse gear, oil level I
S-drive, oil level I
Every 200 hours / at least once a year, included in extended protection
D1 Engine oil and oil filters
1)
R
Reverse gear, oil R
Reverse gear, propeller shaft seal I
S-drive, oil R
S-drive/reverse gear, corrosion protection I
1)
Oil change intervals vary, depending on engine type, oil grade and sulfur content of the fuel. Se avsnitt Oil
Grade and Oil Change Interval.
Every 500 operating hours / at least once per year; included in extended warranty
D2 Engine oil and oil filters
1)
R
Fuel pre-filter and fuel fine filter R
Idle I
Seawater pump impeller I
Vaccum Valve, Cleaning C
1)
Oil change intervals vary, depending on engine type, oil grade and sulfur content of the fuel. Se avsnitt Oil Grade
and Oil Change Interval.
Once per year; included in extended warranty
Folding Propeller C
S-drive, Rubber Sealing between Drive and Hull I
Every 500 operating hours / at least once every 2 years
Heat exchanger C
Injectors I
Valve clearance A
Every 4 years
Coolant R
Every 500 operating hours / at least once every 5 years
Reverse gear, propeller shaft seal R
Every 7 years
S-drive, Rubber Sealing between Drive and Hull R
Maintenance Schedule
32 47702088 05-2011
47702088 - Downloaded from www.volvopenta.com 02/06/2011 18:54:55