Volvo Penta D3 - Scheduled Maintenance Tasks

A
Every 200 hours / At least every
(month)
12 24 48
Inspection with VODIA (Diagnostic Tool)
(1)
I ●
Coolant level and antifreeze mixture I ●
Drive belts, belt tensioner and idler wheels I ●
Batteries, electrolyte level I ●
Air Filter R ●
Fuel pre-filter, filter insert R ●
Fuel fine filter R ●
Seawater filter C ●
Seawater pump, impeller and o-ring I ●
Transmission, oil and filter R ●
Anode - Propeller / Propellershaft. (Must not be painted) R ●
Propellershaft seal. (Lubrication of shaft splines) I ●
Exhaust hose I ●
Seawater Inlet I ●
Crankcase ventilation filter R ●
Start and warm up engine
Engine and transmission, abnormal noises I ●
Engine and transmission, oil / fuel / water leakage I ●
1) Readout if any fault codes and LVD
B
Every 400 hours / At least every
(month)
12 24 48
Impeller in seawater pump R ●
Control cables and seals
(1)
I ●
Engine and transmission, inspect hoses and cable clamping I ●
Engine and transmission, cleaning / painting I ●
1) Xact™
Maintenance Schedule
76 47705992 05-2015 © AB VOLVO PENTA