Walker MTL Detailed Instructions

Page: 2-22
WALKER MANUFACTURING COMPANY
July 2006
SERVICE INSTRUCTIONS
Ident Lubrication No.
No. Location Type Places
Ident Lubrication No.
No. Location Type Places
1 Deck Caster Wheel Fork Pivot Grease 2
2 Blade Drive Gearbox Oil
* 2
3 Tee Gearbox, Deck Oil
* 1
4 Deck Caster Wheel Bearing Grease 2
5 Universal Joint Shaft Assembly Grease
** 1
6 Pivot Assembly, Tilt-Up Deck Grease 4
7 Deck Support Arm Socket Grease 2
8 Body Hinge Point Oil 2
9 FSC Actuator Rod Pivot Pins Oil 2
10 FSC Lever Pivot Grease 1
11 FSC Lever Fork Grease 1
(Grease Slide Area)
12 Steering Lever Pivot Grease 4
13 Deck Support Arm Pivot Grease 2
14 Deck-to-PTO Coupling Grease 1
(Grease Slide Area)
15 Universal Joint Tube Assembly Grease
** 1
16 Universal Joint Quick Connect Grease 1
Spline (Grease Slide Area)
17 Parking Brake Lever Grease 1
18 Gear Axle Oil
*** 2
19 Belt Tightener Pivot, Grease 1
Ground Drive
20 PTO Clutch Lever Pivot Grease 1
21 Clutch Actuator Push Rod Grease 2
22 Brake Actuator Rod and Brake Oil 3
Band Pivot Pins (Clevis)
23 Throttle Control Cable Ends Oil 2
24 Cold Start Lever Grease 1
25 Catcher Hinge Point Oil 2
26 Rear Wheel Bearings Grease 2
27 Engine Dipstick / Oil Filler Oil
*** 1
28 Belt Tightener Pivot, Grease 1
Blower Drive (GHS Model Only)
29 PTO Gearbox Dipstick Oil
*** 1
30 Hydrostatic Drive Oil
*** 2
31 (FSC) Friction Body Pivot Grease 1
* Gearboxes are permanently lubricated and sealed requiring
no scheduled lubrication. Oil level should be checked only
when an oil leak is noted. Refer to Mower Deck Gearbox
Lubrication in this section.
** Grease every eight (8) hours.
*** Refer to Gear Axle Lubrication, Engine Oil, Tractor PTO
Gearbox Lubrication, and Hydrostatic Transmission Fluid
in this section.
NOTE: DGHS42 Tilt-Up Deck is shown for reference. For other
Deck Lubrication Points, Refer to Deck and Carrier Frame
Illustrated Parts Manual.
Lubrication Points - MD

Walker MTL Specifications

General

Brand	Walker
Model	MTL
Category	Lawn Mower
Language	English