30
Maintenance (continued)
Showmobile Maintenance Checklist
1� Check oil level in the hydraulic reservoir�
Fill with Dextron II as needed�
2� Check the operation of the hydraulic pump and motor�
Replace the pump or the motor if necessary�
3� Check the solenoid coil connections, clean and tighten as necessary�
4� Check and clean all spade terminal connections on the hydraulic solenoid valves�
5� Check and clean the ground terminals� (2 places)
6� Check the battery, replace as necessary with an equivalent BCI #8D30 large capacity battery�
7� Clean the battery terminals�
8� Check the tires for wear and/or damage�
9� Check the tire pressure, they should be at 75 – 80 PSI�
10� Check for damaged Trim Seal Gasket on the front and back doors�
Replace if necessary, order gasket # 089A573 - 40 feet�
11� Check the hitch connection used to tow the vehicle�
12� Check and clean the electrical plug used to tow the vehicle, replace if necessary�
13� Check the breakaway switch for the emergency brakes�
Make sure that the brakes engage when the switch plug is pulled out� Do not leave the breakaway switch
plug pulled out for an extended period since that will drain the battery�
14� Check all of the tail lights, turn signal lights and clearance lights�
15� Check the bulbs in the stage lighting, replace as necessary�
16� Lubricate the storage compartment locks�
17� Check the door locks on the front and rear doors�
18� Check the wheel bearings, replace if necessary�
19. Grease the grease ttings on the lift linkage.
20. Check the trim seal on the front and rear ip-down panels, replace if necessary (gasket #089A573).
21� Check the roof and canopy gasket, replace if necessary�
22� Check for any loose screws in the deck tops, tighten as required�
To Next Page
Loading...
General