Wolf ISLANDER - Braking and Lighting Faults

46
Common Faults and Troubleshooting
USER’S MANUAL
Fault system
Fault
Causes
Troubleshooting
Rear Wheel
The rear wheel vibrates
The rear wheel is damaged.
Replace the rear wheel.
The tire pressure is too low.
Increase the tire pressure.
The rear wheel nut is loose.
Tighten the rear wheel nut to specs.
Suspension system
The shock absorber no longer
rebounds
The shock absorber spring is worn out.
Replace the spring.
The shock absorber is improperly adjusted.
Re-adjust the shock absorber.
Braking system
Poor braking performance
The master cylinder has air in it.
Bleed the brake lines.
The brake pads/shoes are worn out.
Replace the brake pads or brake shoes.
Contaminated or old brake fluid.
Adjust the rear brake cable
Flush and bleed brake lines.
Lighting system
The head light will not turn
on
The head light bulb is burnt out.
Replace the headlight bulb.
The headlight switch is faulty.
Inspect headlight switch wires or replace.
The connecting plug is loose.
Check the plug connector.
The fuse is burnt out.
Replace the fuse.
The battery is faulty.
Charge or replace battery.
Stator issues
Check stator connections or replace.