PERIODIC MAINTENANCE
84
YDG Operation Manual
A DANGER
FIRE AND EXPLOSION HAZARD!
• Diesel fuel is extremely flammable and
explosive under certain conditions.
• Before you operate the engine, check
for fuel leaks. Replace rubberized fuel
hoses every two years or every 2000
hours of engine operation, whichever
comes first, even if the engine has
been out of service. Rubberized fuel
lines tend to dry out and become
brittle after two years or 2000 hours of
engine operation, whichever comes
first.
• Failure to comply will result in death or
serious injury.
0000015en
A DANGER
EXPLOSION HAZARD!
• NEVER check the remaining battery
charge by shorting out the terminals.
This will result in a spark and may
cause an explosion or fire. Use a
hydrometer to check the remaining
battery charge.
• If the electrolyte is frozen, slowly warm
the battery before you recharge it.
• Failure to comply will result in death or
serious injury.
0000007en
A DANGER
CRUSH HAZARD!
• When you need to transport a
generator for repair, have a helper
assist you when attaching it to a hoist
and loading it on a truck.
• NEVER stand under a hoisted
generator. If the hoist mechanism fails,
the generator will fall on you, causing
serious injury or death.
• Failure to comply will result in death or
serious injury.
0000008enGen
A DANGER
FIRE AND EXPLOSION HAZARD!
• Diesel fuel is extremely flammable and
explosive under certain conditions.
• Keep the generator at least 3.3 ft (1 m)
away from buildings and other
equipment or sources of combustion
during operation.
• Operate the generator on a level
surface.
• Do not put the generator indoors while
the engine is still hot.
• Failure to comply will result in death or
serious injury.
0000020en
To Next Page
Loading...
