EasyManuals Logo

Zoeller 105 User Manual

Zoeller 105
8 pages
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Page #1 background imageLoading...
Page #1 background image
1
© Copyright 2017 Zoeller
®
Co. All rights reserved.
DRAIN PUMP SYSTEM
MODEL 105 (Korean)
INSTALLATION INSTRUCTIONS
PREINSTALLATION CHECKLIST
FM3034_Ea
0717
Supersedes
New
Notice to Installer: Instructions must remain with installation.
MODEL:_______________________
DATE CODE: __________________
DATE INSTALLED: _____________
1. Inspect your unit. Occasionally, products are damaged during shipment. If the unit is damaged, contact your dealer before using. DO NOT remove the test
plugs from the pump.
2. Carefully read the literature provided to familiarize yourself with specic details regarding installation and use. These materials should be retained for future
reference.
1. To reduce the risk of electrical shock, a properly grounded receptacle of
grounding type must be installed and protected by a ground fault circuit
interrupter (GFCI) and in accordance with National Electrical Code and local
codes.
2. Make certain that the receptacle is within the reach of the pump’s power
supply cord. DO NOT USE AN EXTENSION CORD. Extension cords that
are too long or too light do not deliver sufcient voltage to the pump motor
and could present a safety hazard if the insulation were to become damaged
or the connection end were to fall into the sump.
3. Testing for Ground. As a safety measure, each electrical outlet should be
checked for ground using an Underwriters Laboratory Listed circuit analyzer
which will indicate if the power, neutral and ground wires are correctly con-
nected to your outlet. If they are not, call a qualied electrician.
4. For Added Safety. Pump must be connected to a 3-prong grounded outlet
interrupter device (ground fault circuit interrupter).
5. FOR YOUR PROTECTION, ALWAYS DISCONNECT PUMP FROM ITS
POWER SOURCE BEFORE HANDLING. Single phase pumps are supplied
with a 3-prong grounded plug to help protect you against the possibility of
electrical shock. DO NOT, UNDER ANY CIRCUMSTANCES, REMOVE THE
GROUND PIN. To reduce the risk of electrical shock, a properly grounded
receptacle of grounding type must be installed and protected by a ground
fault circuit interrupter (GFCI) in accordance with national electrical code and
local codes.
6. Installation and checking of electrical circuits and hardware should only be
performed by a qualied, licensed electrician.
7. Risk of electric shock - These pumps have not been investigated for use in
swimming pool areas.
1. Check to be sure your power source is adequate for handling the voltage
requirements of the motor, as indicated on the pump or basin plate.
2. Make sure the pump electrical supply circuit is equipped with fuses or circuit
breakers of proper capacity. A separate branch circuit is recommended, sized
according to the National Electrical Code and local codes for the current
shown on the pump name plate.
3. All plumbing (discharge and vent lines) must be installed to meet local codes.
Unit must be vented. DO NOT USE AN AUTOMATIC PLUMBING VENT
DEVICE SIMILAR TO A "PRO-VENT". Some states require this product to
be installed by a licensed plumber.
4. Repair and service should be performed by Zoeller Pump Company Authorized
Service Station only.
5. CHECK VALVE MUST BE USED TO REDUCE UNNECESSARY CYCLING
OF PUMP.
6. Dewatering pumps are not designed or intended for handling raw sewage.
7. Maximum operating temperature for 105 Drain Pumps must not exceed
54 °C (130 °F).
8. For health reasons, do not unplug, turn off, or disable pump and use pump
tank system as a way to ll up a sink or laundry tray, etc.
9. Unit is designed for above ground installation only.
SEE BELOW FOR LIST OF WARNINGS
CAUTION
SEE BELOW FOR LIST OF CAUTIONS
REFER TO WARRANTY ON PAGE 2.
Notice to Installer: Instructions must remain with installation.
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
TEL: (502) 778-2731 • 1 (800) 928-PUMP • FAX: (502) 774-3624
Visit our web site:
www.zoellerpumps.com
Your Peace of Mind is Our Top Priority
®
60 Hz
P/N 154927

Questions and Answers:

Question and Answer IconNeed help?

Do you have a question about the Zoeller 105 and is the answer not in the manual?

Zoeller 105 Specifications

General IconGeneral
Model105
CategoryWater Pump
Horsepower1/3 HP
Voltage115V
MaterialCast Iron
Max Head20 ft
PhaseSingle
Discharge Size1-1/2 in
Cord Length10 ft

Related product manuals