Arjo Sara 3000 - Preventive Maintenance Schedule; Maintenance Schedule Overview

22
Care and Preventive Maintenance
The Sara 3000 is subject to wear and tear, and the following actions must be performed when specified to
ensure that the product remains within its original manufacturing specification.
Warning
The points on this checklist are the minimum the manufacturer recommends. In some cases due to
heavy use of the product and exposure to agressive environment, more frequent inspections shall be
carried out. Continuing to use this product without conducting regular inspections or when a fault is
found will seriously compromise the user and residents’ safety. Local regulations and standards may
be higher than the manufacturers. Preventive maintenance specified in this manual can prevent
accidents.
Preventive Maintenance Schedule
Warning
The actions marked with ‘S’ must be carried out by qualified personnel, using correct tools and
knowledge of procedures. Failure to meet these requirements could result in personal injuries and/or
unsafe product.
Action/Check
Before each
use
Every week Every
12 months
Every
2 years
Every
3 years
CAREGIVER OBLIGATIONS
Examine the sling, straps and clips for damage or
fraying as required. Refer to sling documentation.
XS
Visually check exposed surfaces for damage, sharp
edges, etc.
XX
Visually check sling attachment points. Do not use if
damaged.
X
Make sure all labels are attached. See Operating
Instructions for location.
X
Check to make sure the handgrips are secure.
Rebond if required.
XS
Examine the charger and wires for integrity and
connections.
S
Operate the Sara 3000 through its full range.
X
Visually check the handset and cable for damage.
X
Perform a full function test on the Sara 3000.
XS
Check operation of the Stop/Reset and System Lower
Override Device.
XS
Check batteries for leakage and/or deterioration.
Replace if required.
XS
Make sure all fixings, screws, nuts are secure and tight.
XS
Check all castor wheels for wear. Replace as required.
XS
Check that the covers fit correctly and are not
damaged. Replace as required.
XS
Check for evidence of corrosion. Replace as
necessary.
XS
Check that batteries will charge when in charging
station.
XS
Replace all batteries every 3 years from installation.
S