26
Item Initial
1 months
Initial
3 Months
Every
3 Months
Every
6 Months
* Valves I I
Spark Plug C C R
Air Filter I Every 20 - 40 hours (more often in
dusty areas)
* Carburetor I I
* Exhaust system I
Fuel hose I I
Engine Oil R R
Brake Fluid level I I I
Brake Hose and joints I I
Brakes I I I
Clutch I I I
Wheels I I
Wheel bearings I I
Brake caliper linings I I I
Front and rear suspension I
Steering system I I I
* Steering shaft lubrication (use Li grease) L
Fittings and Fasteners T T T
I=Inspect and clean, adjust, lubricate or replace, if necessary.
C=Clean R=Replace T=Tighten
* Should be completed by an authorized service center
MAINTENANCE
INSPECTION AND MAINTENANCE
It is very important to inspect and maintain your dirt bike regularly. Follow the
guidelines in the chart. The intervals between periodic services in months are
shown. At the end of each interval be sure to perform the maintenance listed.
MAINTENANCE SCHEDULE
To Next Page
Loading...
