Periodic Maintenance and Lubrication Chart
23
33. Drive chain ‘O’ ring type (If applicable) L At every 500 Kms
34. Drive chain remove, clean, insp. & lubricate (O/H) CL, L CL, L CL, L CL, L At every 10000 Kms
35. Drive chain link lock R R R R Replace at every 10000 Kms
36. Wheel bearing (for non sealed bearings only) C, L C, L At every 20000 Kms
37. Tyre tread wear (replace if worn out till TWI limit) C, R C, R C, R C, R C, R C, R At every 5000 kms i.e. at
every service after 2nd service
38. Front fork oil R R Replace at every 20000 Kms
39. TPS, Thermal sensor (If applicable) C, A C, A C, A C, A C, A C, A C, A C, A At every 5000 Kms
40. Auto choke functioning (If applicable) C, A C, A C, A C, A C, A C, A C, A C, A At every 5000 Kms
41. RSA - Check gas pressure (If applicable) C, A C, A At every 20000 Kms.
42. Starter clutch bush kit for dry type (If applicable) CL, R CL, R CL, R
43. Clutch switch cleaning (If applicable) CL CL CL CL
44. General lubrication L L L L L L L L
45. Swing arm pivot pin lubrication L L Lubricate at every 20000 Kms
46. Engine foundation silent bush (If applicable) R R R Replace at every 15000 Kms
RECOMMENDED FREQUENCY
Servicing
Sr.
No.
Operation
1st
750
2nd
5000
3rd
10000
4th
15000
5th
20000
6th
25000
7th
30000
Kms
C : Check, A : Adjust, CL : Clean, R : Replace, T : Tighten, L : Lubricate
Note : Parts / Lubricants to be replaced as per Periodic Maintenance and Lubrication Chart are mandatory and the same are chargeable to
customer.
To Next Page
Loading...
