Bajaj pulsar F250 User Manual

13
Wiring harness connections, routine &
Conduit / PVC sleeve /Tie band
inspection.
C,A,T
C,A,T
C,A,T
C,A,T
C,A,T
C,A,T
C,A,T
14
Battery connections & health by load
tester. +ve terminal cap tment.
C,A,L,T
C,A,L,T C,A,L,T
C,A,L,T
C,A,L,T
C,A,L,T
C,A,L,T
15
Ignition switch contacts cleaning
CL,L
CL,L
CL,L
CL,L
CL,L
16
HT coil connections (Primary and
Secondary)
C,T
17
Starter motor & starter relay
connections
C,T
C,T
C,T
C,T
C,T
C,T
18
Oil pressure indicator check on
console post ignition ON.
C,R
C,R
C,R
C,R
C,R
C,R
C,R
19
Check fault code, Clear fault history,
Update latest hex le if applicable
C C C C C C C
CL,L,A
CL,L,A
CL,L,A
CL,L,A
20
Sealed Drive chain wear** – Clean,
lubricate & adjust. Replace if required
CL,L,A
CL,L,A
CL,L,A
Sr.
NO.
Activities/Check Points
Recommended frequency - Service interval & Kms
29500~
24500~
19500~
14500~
9500~
4500~
500~
7th
6th
5th
4th
3rd
2nd
1st
750
5000
10000
15000
20000
25000
30000
Damaged conduit / PVC sleeves Protection
by applying electrical tape lm & ensure tie
bandto specic location.
Apply petroleum jelly on battery terminals.
Use Midtronics battery tester.In case of
Battery removal
1.Battery negative terminal to be
disconnected rst
2.latch seat bkt to be removed
Use recommended Wd40 spray
Icon should disappear post engine ON.
After 4000rpm, no icon should be displayed.
During 1st free service use OKS spray or
equivalent for chain cleaning without
removing chain from vehicle
During other services clean chain with
Diesel+ SAE 90 oil ration of 50:50 &
lubricate by SAE 90 Oil.
(Customer to use OKS chain lube spray
or equivalent spray at every 500 kms
Setting of chain play/slackness (20-30 mm
in 16/ both wheel on around)
35
Remarks

Bajaj pulsar F250 Specifications

General

Displacement	249.07 cc
Max Power	24.5 PS @ 8750 rpm
Max Torque	21.5 Nm @ 6500 rpm
Transmission	5-speed
Fuel Tank Capacity	14 liters
Brakes	Disc
Kerb Weight	164 kg
Rear Suspension	Monoshock with Nitrox
Front Tyre	100/80-17
Rear Tyre	130/70-17
Wheelbase	1351 mm
Ground Clearance	165 mm
Seat Height	795 mm
Headlamp	LED
Tail Lamp	LED
Instrument Console	Digital
Speedometer	Digital
Tachometer	Digital
Odometer	Digital
Tripmeter	Digital
Fuel Gauge	Digital
Clock	Digital
Battery	12V
ABS	Single Channel ABS
Front Suspension	Telescopic
Starting	Electric
Clutch	Wet, Multi-Plate
Frame Type	Tubular
Colors	Racing Red, Techno Grey
Ignition	Electronic ignition (ECU)