Bauer G 120 II V - Air Purification Cartridge Operating Hours

138 pages

To Next Page

To Previous Page

MNL-126509

April 4, 2013 Page 121

8.4.2 Air Purification Cartridge Operating Hours

Date

Operating

hours

Ambient temp. + 18°F

during compression

Correction

factor

Adjusted cartridge hours

Today Total

Main Page

How to Use this Manual11
How to Use the Replacement Parts List12
How to Use the Appendix13
Unit Specifications14
Description15
Operator Interface16
Main Menu Screen17
Alarms History18
Configuration19
Parameters20
To Start Unit21
Screen Flow24
Maintenance and Parts25
Air Flow Diagram26
Compressor Lubrication27
Oil Change Interval28
Oil Change29
Inter-Stage Separator30
Maintenance31
General Instructions for Changing the Valves32
Changing the IK120 II C & G, 1St Stage Valve33
Removing the IK120 II C & G, 2Nd Stage Valves34
Reassembling the Valves of the 2Nd Stage35
Removing the IK120 II C & G, 3Rd Stage Valves36
Reassembling the Valves of the 3Rd Stage37
Replacement Parts List38
Inlet Assembly56
Troubleshooting and Repair57
Repair Instructions58
Three Stage Automatic Condensate Drain System59
Normal Operation60
Standstill Drainage61
ACD Replacement Parts List62
ACD Valve and Manifold Assembly63
Condensate Collector64
Condensate Collector Replacement Parts List65
Introduction66
Manual Condensate Drainage67
Purification System Dataplate68
Industrial Purification System Configurations69
Calculating the Maximum Cartridge Operating Hours70
Correction Factor for Cartridge Operating Hours71
Air Purification Cartridge Operating Hours Form72
P1 Purification System73
Component Description74
Chamber75
Bleed Valve76
Cartridge Replacement77
Leaking at the Safety Bore78
Replacement Parts List79
Oil and Water Separator Parts List80
Chamber Parts List81
Vertical Compressor Drive82
Replacement Part List83
Overview85
Wiring Diagram86
Electrical Panel Components87
Replacing the PLC88
Hourmeter89
Motor Starter90
Power Supply91
Securus ® Electronic Moisture Monitor System92
Compressor High Temperature93
Motor Starter Overload Trip94
Analog Inputs to the PLC95
Wiring Harness Layout96
Replacement Parts List98
Electrical Panel, Front View99
Electrical Panel, Bottom View100
Parts List for Models with a 5 Horsepower Motor106
Parts List for Models with a 7½ Horsepower Motor107
Parts List for Models with a 10 Horsepower Motor108
Parts List for Models with a 15 Horsepower Motor109
Parts List for Models with a 20 Horsepower Motor110
Description111
Nonadjustable Valves113
Safety Valves114
Safety115
Safety Warning Labels117
Unpacking, Handling and Installation118
Installation of the Compressor Unit119
Ventilation120
Forced Ventilation121
Outside Air Source122
Installation Procedures123
Figure 8-4 Incoming Power Wiring Label124
Pneumatic Leaks125
Long Term Storage126
Preventive Maintenance During Storage127
Reproducible Forms128
Air Purification Cartridge Operating Hours131
Record of Operating Hours132
Reference Data133
Approved Lubricants Chart134
Additional Documents135

Bauer G 120 II V - Air Purification Cartridge Operating Hours

Table of Contents

Related product manuals