BENDIXKing XCRUZE 110

Need help?

Do you have a question about the BENDIXKing XCRUZE 110 and is the answer not in the manual?

Summary

Introduction

How to Use This Manual

General guidance on using the manual, including symbols and units.

References

Lists standard references and other publications relevant to the manual.

Acronyms and Abbreviations

Defines acronyms and abbreviations used throughout the manual.

General Information

Introduction to xCruze 110 Autopilot

Introduces the xCruze 110 Autopilot and its purpose.

Mechanical Considerations

Servo Arm Movement and Control Limits

Details servo arm movement, over-center prevention, and travel limit considerations.

Mechanical Connection Methods

Details connecting servos via push-pull tubes or cable-driven systems.

Controller Installation

Mounting the Autopilot Controller

Guidelines for mounting the autopilot controller unit in the aircraft panel.

Wiring the Autopilot Controller

Specifies wire gauge, routing, and precautions for controller wiring.

Pitot and Static Connections

Details requirements for pitot and static line connections to the autopilot.

RFI;EMI Considerations

Addresses radio frequency and electromagnetic interference for the autopilot.

Ground Checkout

Ground Checkout Procedure

Outlines steps for verifying servo movement on the ground before flight.

Electrical Pin Information

P101 Connector Pin Functions

Explains the function of each pin on the main 25-pin connector P101.

Autopilot Wiring Diagram

Gemini Autopilot Wiring Diagram

Provides a detailed wiring diagram for the Gemini Autopilot system.

Controller Cut-outs and Dimensions

Controller Dimensions and Panel Cutout

Shows physical dimensions, panel cutout, and connector details for the controller.

GPS Setup Guide

General GPS Data Output Requirements

Covers data output rates, baud rates, and general connection advice for GPS units.

Garmin GPS III Configuration

Configuration steps for Garmin GPS III for autopilot data output.

Garmin GPS 92 Configuration

Configuration steps for Garmin GPS 92 for autopilot data output.

Garmin GPS 195 Performance and Setup

Discusses Garmin GPS 195 data output and potential performance issues.

Garmin GPS 196;295 Configuration

Configuration for Garmin GPS 196/295 for autopilot data output.

Garmin GPS 296 Configuration

Configuration steps for Garmin GPS 296 for autopilot data output.

Garmin GPS 396;496 Configuration

Configuration for Garmin GPS 396/496 for autopilot data output.

Lowrance Airmap 100 Configuration

Configuration for Lowrance Airmap 100 for autopilot data output.

Lowrance Airmap 1000;2000 Configuration

Configuration for Lowrance Airmap 1000/2000 for autopilot data output.

AvMap EKP IV Configuration

Configuration for AvMap EKP IV for autopilot data output.

Garmin 155 XL;250 XL;300 XL Connections

Details connections for Garmin 155XL/250XL/300XL to the autopilot.

Garmin 430 and 530 Connections

Details connections for Garmin 430/530 to the autopilot.

UPSAT GX-50;60;65 Configuration

Configuration for UPSAT GX-50/60/65 for autopilot data output.

Garmin AT GNS480 Configuration

Configuration for Garmin AT GNS480 for autopilot data output.

KMD 150 Configuration

Configuration for KMD 150 for autopilot data output.

Garmin GTN-650 Connections

Details connections for Garmin GTN-650 to the autopilot.

Garmin 695;696;795;796 Configuration

Configuration for Garmin 695/696/795/796 for autopilot data output.

Garmin Aera 500-510-550-560 Configuration

Configuration for Garmin Aera 500-510-550-560 for autopilot data output.

Garmin G3 X Connections

Details connections for Garmin G3X to the autopilot.

Installation Support

Technical Support Contact Information

Provides contact details for technical support and installation assistance.