Autostacker™ Parking Lift 47 P/N 5900002 — Rev. D — August 2019
Maintenance
⚠ DANGER: Before performing any maintenance on your Autostacker, make sure it is
completely disconnected from power
. If your organization uses
Lockout/Tagout policies, make sure to implement them after connecting to a power
source.
To maintain your Autostacker:
• Daily: Keep the Autostacker clean. Wipe up any spills, clean any dirt.
• Daily: Make a visual inspection of all moving parts and check for damage or excessive wear.
Replace any damaged or worn parts before using the Lift.
• Daily: Make sure Safety Locks are in good working condition. Do not use your Autostacker if the
Safety Locks are damaged or excessively worn.
• Twice a Week: Sweep the Bases, removing all debris. Pay special attention to the Safety Locks
and the wheel tracks; if these areas are dirty, the Lift may not work normally.
• Weekly: After cleaning the wheel tracks, apply a lubricant (WD-40®, for example) to the wheel
tracks to help them roll easily. The wheels are self-lubricating.
• Weekly: Check all controls, including emergency stop, to make sure they are functioning
normally.
• Weekly: Check all labels on the Autostacker. Replace them if they are illegible or missing.
• Every Two Weeks: Lubricate the grease fittings on the Lift. There are four Grease Fittings on
each side of the Autostacker: one where the bottom of the Cylinder meets the Base, one where
the top of the Cylinder meets the Leg, one on the underside where the two Legs cross, and one
where the Leg meets the Top Connector Tube. We recommend using white lithium grease or
similar.
• Monthly: Check the Hydraulic Fluid levels. Refill if low.
• Every two months: Check all Bolts to make sure they are tight. If not, tighten them.
• Every three months: Damp wash all exposed surfaces to protect against corrosive debris.
• Every six months. Check the electrical wiring for loose connections; if you find any, secure
them.
⚠ WARNING: Do not operate your Autostacker if you find issues; instead, take it out of service,
then contact your Autostacker dealer, visit autostacker.com/support, email
support@autostacker.com, or call (888) 977-8225.
To Next Page
Loading...
