Safety regulations
BOMAG
15
BPR 35/40 D BPR 35/60 D
Environment
Sections marked like this highlight activities
for the safe and environmental disposal of fu-
els and lubricants as well as replaced parts.
Safety stickers on the machine
Keep safety stickers in good condition and legible
and follow their meaning.
Replace damaged and illegible safety stickers.
Loading the machine
Secure the machine against turning over or slip-
ping off.
Persons are highly endangered if they
l step under loads being lifted or
l stand under loads being lifted
Secure the machine on the transport vehicle
against rolling off, slipping and turning over.
Starting the machine
Before starting
Become acquainted with the equipment, the con-
trol elements, the working principle of the machine
and the working area.
Wear your personal protective outfit (hard hat,
safety boots, etc.). Wear ear defenders.
Before starting the machine check whether:
l the machine shows any obvious faults
l all guards and safety elements are in place
l the controls are fully functional
l the machine is free of oily and combustible
material
l all grips are free of grease, oils, fuel, dirt, snow
and ice.
Use only machines which are serviced at regular
intervals.
Do not use any starting aids like start pilot or ether.
For starting move your feet out of the danger zone
of the base plate.
Starting in closed rooms
Exhaust gases are highly dangerous! Always en-
sure an adequate supply of fresh air when starting
in closed rooms!
Operation
Operate the machine only with the steering rod
folded down.
Guide the machine so hat your hands do not hit
against solid objects, danger of injury.
Watch out for unusual noises and development of
smoke. Perform trouble shooting and have the
fault corrected.
Operate the machine only with full engine speed,
as otherwise the centrifugal clutch will be de-
stroyed.
Do not let the machine run unattended.
Parking the machine
Park the machine on level, firm ground.
Before leaving the machine:
l park the machine so that it cannot turn over,
l shut the engine down.
Mark machines, which could be in the way, with a
clearly visible sign.
Filling the fuel tank
Refuel only with the engine shut down.
Do not refuel in closed rooms.
No open fire, do not smoke.
Do not spill any fuel. Catch running out fuel, do not
let it seep into the ground.
Maintenance
Maintenance work must only be carried out by
qualified and authorized personnel.
Keep unauthorized persons away from the ma-
chine.
Do not perform service work while the engine is
running.
If possible, park the machine on level and firm
ground.
Working on the engine
Drain the engine oil at operating temperature -
danger of scalding!
Wipe off spilled oil, catch running out oil and dis-
pose of environmentally.
Go to Discount-Equipment.com to order your parts
To Next Page
