6 720 220 045
Revised 05-12 Subject to change without prior notice
3
CP/BP Series
MODEL NOMENCLATURE
Table of Contents
SUPPLY AIR LOCATION:
T - TOP (VT ONLY)
S - STRAIGHT THRU (HZ ONLY)
E - END BLOW (HZ ONLY)
RETURN AIR LOCATION:
L - LEFT
R - RIGHT
WATER CONNECTION LOCATION
F - FRONT
SERIES:
CP/BP
NOMINAL CAPACITY:
MBTUH
VOLTAGE DESIGNATION:
1- 208-230/1/60
CABINET CONFIGURATION:
VT - VERTICAL
HZ - HORIZONTAL
WATER TO REFRIGERANT HEAT EX:
C - COPPER
N - CUPRO-NICKEL
CP/BP 048 - 1 VT C - F L T
TABLE OF CONTENTS
Model Nomenclature ............................................. 3
Initial Inspection ................................................... 4
General Description .............................................. 4
Moving and Storage .............................................. 4
Safety Considerations ........................................... 4
Location ................................................................ 4
Installation ............................................................ 5
Mounting Vertical Units ......................................... 5
Mounting Horizontal Units .................................... 5
Condensate Drain ................................................. 6
Duct System .......................................................... 6
Electrical ............................................................... 7
Thermostat Connections ...................................... 8
Safety Devices and the UPM Controller ................. 8
Sequence Of Operation ...................................... 10
Unit Options........................................................ 10
Fluid Differential Pressure Switch ....................... 13
Water Piping ....................................................... 13
Well Water Systems ............................................. 13
Fresh Water Systems ........................................... 14
Earth Coupled Systems ....................................... 15
Unit Start-up ....................................................... 15
Heat Recovery Package ....................................... 15
Water Tank Preparation ....................................... 16
HR Water Piping ................................................. 16
Typical Connection Piping ................................... 16
Water Tank Rell ................................................. 17
Initial Start up ..................................................... 17
Maintenance ....................................................... 17
In-warranty Material Return ................................ 18
Unit Specications .............................................. 18
Physical Data ................................................ 18
Dimensions ................................................... 19
Fluid Pressure Drops ..................................... 20
Air Temperature Rise/Fall .............................. 21
Refrigerant Pressure Ranges ......................... 22
Blower Performance ..................................... 23
Typical Wiring Diagrams ...................................... 24
Unit Check-out Sheet .......................................... 28
Troubleshooting .................................................. 29
To Next Page
Loading...
Need help?
General