Burnham SERIES 2 - Schematic Diagram Legend; Wire Code; Ladder Diagram Legend; Wiring Diagram, Intermittent Ignition and Continuous or Gravity Circulation

52 pages

To Next Page

To Previous Page

Figure 13: Wiring Diagram, Intermittent Ignition and Continuous or Gravity Circulation

Main Page

Dimensions3
Left Side View3
Front View L/Door3
Right Side View3
Boiler Locate/Installation4
Remove Crate4
Provide Clearance/Ventilation4
Minimum Clearances4
Connect Gas Service5
Boiler Piping6
Install Draft Hood7
Install Blocked Vent Switch7
Equivalent Length of Fittings7
Specific Gravity Correction Factors7
To Meet Federally Mandated Efficiencies8
Install Vent Connector9
If an Existing Boiler Is Removed9
Plug-In Damper Installation10
Install a Room Thermostat11
Install Electric Wiring11
Vent Damper Sequence of Operation11
Wiring Diagrams and Heat Anticipator Settings11
Vent Damper Schematic Wiring Diagram12
Wiring Diagram13
Wiring Diagram, Intermittent Ignition and Intermittent Circulation14
Sequence of Operation15
Normal Operation15
Safety Shutdown15
Schematic Diagram Legend16
Wire Code16
Ladder Diagram Legend16
Wiring Diagram, Intermittent Ignition and Continuous or Gravity Circulation16
Wiring Diagram, 24 Volt Standing Pilot with Continuous or Gravity Circulation18
Wiring Schematic, Zone Valves19
Wiring Schematic, Zone Circulators19
Operating Instructions20
Main Burner Check20
Initial Start20
Instructions to Put the Boiler in Operation21
Top View of SV9500, SV9600 and VR Gas Valves21
For Your Safety Read before Operating22
To Turn off Gas to Appliance22
Top View of Honeywell SV9501 and SV9601 Gas Valves22
Check Gas Input Rate to Boiler24
Main Burner Flames24
Check Pilot Burner Flame24
Check Thermostat Operation25
Check High Limit Control25
Check Ignition System Safety Shut-Off Device25
Combustion Chamber Burn-Off25
Typical Pilot Flame, Honeywell Q345026
Troubleshooting Guide, Honeywell Intermittent Ignition27
Service28
Vent System28
Cleaning Boiler Flues28
To Remove Burners for Cleaning, Changing Orifice Plugs, or Repairs28
Clean Firebox29
Install Burners29
Removal or Replacement of Pilot Assembly or Pilot Assembly Parts29
Lubrication30
Pilot Burner Location30
Repair Parts30
Burnham Corporation Regional Offices31
Section Assembly and Canopy Group32
Base Assembly34
Manifold and Main Burners (1 Inch Main Burners)36
Manifold and Main Burners (50 MM Main Burners)38
Manifold and Main Burners (40Mm Main Burners)40
Pilot Burner and Gas Valve, Intermittent Ignition, Natural Gas44
Pilot Burner and Gas Valve, Intermittent Ignition, Lp/Propane44
Jacket Assembly, Complete46
Water Trim48
Vent Damper Carton51
Draft Hood Carton51

Burnham SERIES 2 - Schematic Diagram Legend; Wire Code; Ladder Diagram Legend; Wiring Diagram, Intermittent Ignition and Continuous or Gravity Circulation

Table of Contents

Related product manuals