Name: Carrier Transport Air Conditioning
Brand: Carrier
Rating: 4 (1 reviews)

Default Chapter1

Section15

Condensers15

Introduction15
- Description15
System Requirements Label15
Table 1-1 ADDITIONAL SUPPORT MANUALS15
Figure16
Figure 1-1 Condenser Model CM2/3 - Serial Number Location16
Figure 1-2 GEN 4 Evaporator Model - Serial Number Location16
Table 1-2 CARRIER TRANSPORT AIR CONDITIONING SYSTEMS (GEN 4/5)16
Figure 1-3 GEN 5 Evaporator Model (All) - Serial Number Location17
Figure 1-4 GEN 4, IW-2 & IW-7 - Serial Number Location17
Figure 1-5 GEN 4, IW-1 - Serial Number Location17
Figure 1-6 CM-7/11 Rooftop Condensers (no Longer Offered) - Serial Number Location18
Figure 1-7 KR-2/KR-3 Rooftop Condensers - Serial Number/Pid Location18
Figure 1-8 KR-4 Rooftop Condenser - Serial Number/Pid Location18
Figure 1-9 Typical Component Locations19
System Components19
Cooling Cycle20
- Figure 1-10 Refrigerant Flow Diagram20
- Table 1-3 GEN 4 EVAPORATORS21
- Table 1-4 GEN 5 EVAPORATORS21
- Table 1-5 GEN 5 EVAPORATORS -- VARIABLE SPEED22
- Table 1-6 IN--WALL EVAPORATORS22
- Pre-Installation Inspection23
- Cap Plugs24
- Evaporators24
- Location24
- Figure 2-1 Template for EM-1 and EM-2 (GEN 4)25
- Rear Mounted Evaporators25
  - Table 2-1 GEN 4 EVAPORATORS25
  - Table 2-2 GEN 5 EVAPORATORS25
  - Figure 2-2 Measurement to Wall (GEN 4)26
  - Figure 2-3 Measurement to Wall (GEN 5)26
  - Figure 2-4 7/16 Inch Holes in Bus Roof26
  - Figure 2-5 Carriage Bolts & Sealant26
  - Figure 2-6 Sealant Pattern on Mounting Channel26
  - Table 2-3 DISTANCE to BACK WALL (GEN 4)26
  - Table 2-4 DISTANCE to BACK WALL (GEN 5)26
  - Figure 2-10 Evaporator Mounted to Flat Ceiling27
  - Figure 2-11 Mounting Channel Sealing27
  - Figure 2-7 Carriage Bolt Sealing27
  - Figure 2-8 Locking Pliers Clamped to Carriage Bolts27
  - Figure 2-9 Locking Pliers & GEN 4 Evaporator27
  - Figure 2-12 Block Valve Insulation28
  - Figure 2-13 Drain Line & Condensate Valve28
  - Figure 2-14 Installed GEN 4 Evaporator28
  - Figure 2-15 Return Air Grill28
  - Figure 2-16 Painted Mounting Channel28
  - Figure 2-17 GEN-4/5 Front/Rear (EM-1, 2, 6, & 14) Evaporator & Installation Hardware29
  - Figure 2-18 Rear Mount Evaporator (GEN 4) - Installed29
  - Figure 2-19 Rear Mount Evaporator (GEN-5) - Installed30
  - Figure 2-20 EM-6 (GEN 4) Rear Mounted in an Extended Roof Van30
  - Luggage Compartment Evaporator30
  - Em-3 Evaporator Gen 4 or Gen 531
- Figure 2-21 EM-3 Installation Diagram31
- Figure 2-22 Side-Mount Template32
- Figure 2-23 Drain Line Elbows32
- Figure 2-24 Side Mount Installation Instructions (Typical)33
- Figure 2-25 Side Mounted Evaporator GEN 433
- Figure 2-26 EM-2 (Gen V) Side-Mount - Free Blow, Installed (Complete)34
- Figure 2-27 EM-9 Ducted Evaporator - Hose & Harness Routing35
- Figure 2-28 Punching out Louver Holes36
- Figure 2-29 End Cap with Louver36
- Figure 2-30 EM-9 Ducted Evaporator - Location - Completed Assembly36
- Figure 2-31 School Style Ducting-Passenger Side36
- Figure 2-32 School Style Ducting-Drivers Side36
- Figure 2-33 Side Mounted Hose Routing (Using 455 Angles)37
- Figure 2-34 Side Mounted Hose Routing (Straight)37
- Em-17 Evaporator38
- Figure 2-35 EM-17 Installed38
- Figure 2-36 In-Wall Marked for Cut-Out39
- Rear Mounted In-Wall Evaporator39
- Table 2-5 IW-1 EVAPORATOR DIMENSIONS39
- Table 2-6 IW-2 EVAPORATOR DIMENSIONS39
- Table 2-7 IW-14 EVAPORATOR DIMENSIONS39
- Figure 2-37 In-Wall Cut-Out (Panel Removed)40
- Figure 2-38 In-Wall Cut-Out (Insulation Removed)40
- Figure 2-39 In-Wall Cut-Out (Wires Supported)40
- Figure 2-40 Bus Electrical Harness Ground41
- Figure 2-41 In-Wall Hose/Drain Line Cut-Out41
- Figure 2-42 In-Wall Hose Cover Back41
- Figure 2-43 Bus Light Removed for Access41
- Figure 2-44 Hose/Harnes/Drain Routed to IW42
- Figure 2-45 IN-Wall Installed (Left-Side)42
- Figure 2-46 In-Wall Installed (Right-Side)42
- Figure 2-47 Hose Cover Installed (Left-Side)43
- Figure 2-48 In-Wall with Trimmed Cover (Rear)43
- Figure 2-49 Front In-Wall Template44
- Figure 2-50 Hose/Harness/Drain Line Routing & Access Cut-Out44
- Figure 2-51 In-Wall Front Installation44
- Front Mounted In-Wall Evaporator44
- Figure 2-52 In-Wall Installed (Front Mount)45
- Figure 2-53 Hose Routed over Door (Closeup)45
- Figure 2-54 Hose Routed over Door45
- Figure 2-55 In-Wall with Trimmed Cover (Front)46
- Figure 2-56 In-Wall Cover - Locking Tabs46
- Figure 2-57 In-Wall Cut-Out (TBB)47
- Figure 2-58 IW-1 Installed in TBB (Rear)47
- Figure 2-59 IW-1 Secured to Structure Rail TBB47
- In-Wall Evaporator - TBB47
- Mounting (Rooftop)48
- Mounting (Skirt)48
- Obstructions48
- Protection48
- Skirt Supports48
- Voltage48
Figure28
Figure47
Condensers48
CM-2, CM-3, CM-4, CM-5, & CM-14 Skirtmounted Condenser Assemblies49
- Skirt--Mounted Installations49
- Table 3-2 SKIRT MOUNTED COND. DIMENSIONS49
- Figure 3-1 3/8 Inch Carriage Bolts Thru Floor50
- Figure 3-2 Condenser Mounted with Hardware50
- Figure 3-3 Installation Drawing (Typical Skirt Mounted)51
- Figure 3-4 CM-2 with Chassis Mounted Grill on an Extended Roof Van (Custom)51
CM-5 Condenser52
Condenser52
Figure 3-5 CM-3 with Chassis Mounted Grill in a Cut-A-Way Chassis52
Figure 3-6 CM-5 Installation Drawing52
Rooftop Condenser Assembly53
- Rooftop Condenser Installations53
- Table 3-3 ROOF--MOUNT COND. DIMENSIONS53
- Figure 3-10 KR4 Condenser Mounted Without Mounting Channels (Side View)54
- Figure 3-7 Mounting Options54
- Figure 3-8 KR4 Condenser Mounted Without Mounting Channels (Front/Back View)54
- Figure 3-9 KR4 Condenser Mounted with Mounting Channels (Front/Back View)54
- Figure 3-11 KR4 Condenser Mounted with Mounting Channels (Side View)55
- Figure 3-12 Condenser Feed-Thru Plate KR4 (Single Loop)55
- Figure 3-13 Condenser Feed-Thru Plate KR4 (Dual Loop)55
- Figure 3-14 Condenser Feed-Thru Plate KR2/356
- Figure 3-15 Condenser Feed-Thru Plate KR2/356
- Connecting to Side-Mounted Evaporators57
Kr2 & Kr356
And CM-3 Stacked Condenser Assemblies57
Figure 3-16 Stacked Condenser Assembly (Side View)58
Figure 3-17 Stacked Condenser Assembly (Bus Skirt View)58

Hose Routing59

Section76

Electrical76

Mount Kits and Compressors82

Evacuation87

Charging Procedures90

Introduction90

Table93

Table 8-5 CARRIER TRANSPORT AIR CONDITIONING SYSTEM PERFORMANCE CHART93

Section94

Leak Checking94

Final (Check-Out Sheet)97

Installation Check-Out97

Carrier Transport Air Conditioning User Manual

Table of Contents

Questions and Answers:

Carrier Transport Air Conditioning Specifications

Related product manuals

Brand	Carrier
Model	Transport Air Conditioning
Category	Air Conditioner
Language	English