BATTERY PACK CARE AND MAINTENANCE
DANGER
1.
While charging, batteries emit hydrogen which is an explosive
gas. Keep the vehicle in well
ventilated areas while charging.
2.
Do not smoke or expose sparks or open flames near the vehicle.
3.
The electrolyte in the batteries is highly acidic and poisonous. Avoid contact with skin, eyes, and
clothing. Severe burning and scaring may
result.
4.
Remedial measures in case of contact with battery acid:
o External: Flush with water for 15 minutes. Call physician immediately.
o Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable oil. Call
physician immediately.
o Eyes: Flush with water for 15 minutes. Call physician immediately.
WARNING
•
Wear safety glasses while working on the vehicle or charger. Wear a full- face shield and
rubber
gloves while working on or near the
batteries.
•
Use insulated tools while working on any electrical components.
CAUTION
Turn the vehicle and all accessories off while charging. The batteries in this vehicle are specifically designed
deep cycle batteries. Automotive batteries should never be used in this vehicle. The same type and size lead-
acid batteries should be used if replacements are necessary. Alternative batteries such as sealed batteries and
glass mat batteries will require a different charging system and should not be used. Always consult your dealer
or battery manufacturer for proper care and maintenance.
It is important to properly condition new batteries. New batteries will take numerous charges to reach their full
potential. During this period, it is important not to exceed a 50% discharge level. Batteries should be fully
charged before first use of vehicle, before removal from storage, and before use each day.
Charge batteries whenever possible; avoid deep discharging of batteries as it will shorten their life.
Battery Care
1.
Keep batteries clean. Ensure the battery cell tops are secure. Wash the battery’s tops and terminals
with a solution comprised of 1-gallon water and 1 cup baking soda. Do not allow solution to enter
the batteries. Rinse off residual solution.
2.
The electrolyte level in the batteries should be checked weekly by removing the battery caps and
visually inspecting the level as
shown below.
To Next Page
Loading...
