GENERAL WARNINGS
Any reference to Battery Care or maintenance is intended as general safety guidelines. Always consult and
follow the recommendations of your battery manufacturer if contrary to those expressed herein. Never exceed
your skill level by performing services you are not trained to accomplish. When in doubt, Stop and call a
professional.
DANGER
• The E-Merge contains batteries which can emit quantities of explosive gases. Keep the vehicle in a well-
ventilated area and away from sparks and open flames.
• Ventilate when charging or operating the vehicle in enclosed areas.
• Do not perform service or maintenance on batteries while vehicle is charging.
• The E-Merge does not offer protection from lightning, flying debris, or other storm hazards. Upon indication
of severe weather conditions, seek appropriate shelter immediately.
WARNING
• Inspect battery terminals, cables and batteries before each use.
• Always wear a full-face shield, rubber gloves and rubber apron when working with or near batteries.
• Turn the ignition switch to the off position, remove the key, unplug the charger and place the run/tow switch
to the tow position before
inspecting or performing any type of service on the
vehicle.
• Connections should be tight and free of corrosion.
• Utilize insulated tools only when working with electrical connections.
• The tightness of the battery terminal nut should be between 95-105-inch pounds of torque. Do not over
tighten. Loose and/or over tightened connections can cause battery failure, explosion and or fire.
• Do Not Overfill the Batteries and keep batteries clean and free of moisture.
• If any high heat condition or burning smell is noticed immediately park the vehicle in a safe location, place
the ignition in the off position, move yourself and passengers away quickly to a safe distance from the vehicle
and contact your dealer for assistance and repair. If fire or smoke is detected contact your local fire
department immediately. Do not store your vehicle inside if any of these conditions exist.
• Only use recommended batteries of the correct size.
To Next Page
Loading...
