EdgeStar IB450SSP Service Manual

17
Other problems
Problem
Check point
Possible Cause
Correction
The Unit Body
is Electrified
Ground
The ground plug is broken.
Replace power cord.
Lines
Shorted wiring.
Adjust, reconnect
/replace wires.
Electric component
Shorted electric component.
Replace component.
Scales Occur
Frequently
Inside Unit
Water Quality
The water quality is poor.
Install a water-softener or
water filter in front of the
water inlet valve.
Noise During
Operation
Water Inlet Valve
Defective water inlet valve.
Replace the water inlet
valve.
Compressor
Excessive noise/vibration.
Tighten compressor bolts
or replace the
compressor.
Water Pump
Defective water pump.
Replace the water pump.
Cooling System
Refrigeration pipes vibrating.
Adjust pipes.
Leveling Legs
The feet are not leveled.
Level and lock the feet.
Fan Motor
The fan motor is loose or
defective.
Repair or replace the fan
motor.
Water Leaking
Out of Unit
Water Supply
Connection
Water connection leaking.
Tighten fitting. See
“Connecting the water
line.”
Water Pump Drain Cap
Leaking around cap.
Tighten fitting.
Drain Pipe Connection
Drain pipe connection leaking.
Tighten fitting. See
“connecting the drain.”
Ice Harvesting
is Difficult
Hot gas valve
The hot gas valve damage.
Replace the hot gas
valve.
Evaporator
The evaporator is dirty or finish
is damaged.
Clean the ice mold, or
replace the evaporator.
Refrigerant
Refrigerant leaks
Recharge
Ambient Room and
Water Temperature
Temperature is too low.
Adjust the temperature.
Ice Cube Size
Size is too large.
See “Ice Cube Size
Adjustment Guidelines” in
this manual.
Ice Slide Way
Ice slide way is installed
incorrectly.
Reinstall ice slide so
harvested ice does not
get stuck or blocked.

EdgeStar IB450SSP Specifications

General

Brand	EdgeStar
Model	IB450SSP
Category	Ice Maker
Language	English