Enviro PILATUS PC12 - Special Tools, Fixtures, and Equipment; General

Component Maintenance Manual
12037 N Highway 99
Seminole, OK 74868
Phone (405) 382-0731
Fax (405) 382-0737
http://www.enviro-ok.com
Copyright © 2017
ATA 21-00-23
Page | 66
Revision 10
June 1, 2017
SPECIAL TOOLS, FIXTURES, AND EQUIPMENT
TASK 21-00-23-99F-803
10.0 SPECIAL TOOLS/EQUIPMENT
SUBTASK 21-00-23-99F-014
10.1 General:
10.1.1 This section describes the necessary tools and test equipment required to perform
maintenance, functional testing, troubleshooting, and repair procedures. Equivalent test
equipment may be substituted only if it meets the listed equipment specifications.
• Regulated Shop Air 40 PSIG
• Fin comb SK1250101-13
• Miscellaneous hand tools and socket set
• Shop vacuum with soft utility brush
• Vacuum pump, air or electric 0-30 in.hg.
• Gaseous dry Nitrogen, regulated source 0-500 PSIG
• Reclaim/Recycle Cart (R-134A) (Robinair model # 342000) (preferred) or R-134A refrigerant
charging manifold with gauges and hoses (low pressure gauge, 0-300 PSIG), (high pressure
gauge, 0-600 PSIG).
• Thread sealant primer Loctite 7471
• Thread sealant Loctite 569
• RTV sealant 11602 Black
• Hose adapter 1/2 in. male ACME to 1/4 in. female flare
• Leak check fluid soap solution (Spec MS-SNOOP-GAL)
• Refrigerant oil RL-100S
• External or aircraft power source 200 amp.
• Inspection mirror
• Thermometer 0-150°F
• Flashlight or service lamp
• Refrigerant R-134A
• Kent-More Flush Adapter J42939
• Small “rare earth” magnet
• Tape