FUEL AND LUBRICANT
ThiS
is a two cycle eng me that requires
lubricant
to
be m1xed
w1th
gasolme Follow
these instructions.
0
NOTE: Recommended lubricant and gasoline
must
be
properly
mixed
or
sarrous damage
wt/1
result to the engme.
RECOMMENDED
LUBRICANT
Use
EVINRUDE LUBRICANT
(m
Canada use
OMC
two
cycle
motor
oil)
wh1ch
is
BIA cert
1
fted
for
service TC-W
(Two
Cycle-Water
Cooled)
It
1s
formulated
to
g1ve
best
engme performance with least combustion chamber deposits, least piston varnish,
maximum spark plug
l1fe,
and best lubrication EVINRUDE
LUBRICANT
can
be
purchased from your DEALER in the following packages·
~--------------------------~
Smgle pmt cans (enough for
6
U.S. gallons
(5
Imperial)
of
gasoline) . . . . . .
..............
.
S1x-Pack of pmt cans
Case of 4 six-packs or
total of
24
pints
.................
.
Always keep
an
ample supply on hand. Do not settle
for
less than the BEST Other
addit1ves
such
as
"tune-ups." "tonics," "friction reducing
compounds,"
etc. are un-
necessary and should not be used in your engine, except
as
described in this manual.
If
EVINRUDE LUBRICANT
Is
not available, another
BIA
certified TC-W or
rc-2
lubricant (oil) may
be
used.
r;;;l
NOTI!:
Avotd the
use
of
the fo/lowmg,
as
they
wt/1
contnbute
to detenoration
t=l
of
your eng
me
and shorten spark plug Ide:
AVOID USE OF:
•
Automotive oils
• Premix fuel of unknown oil
quality
• Premix fuel richer than
50:1
ratio
MCOIIIIDDI!D
GASOLINE
Use
gasoltne with the following minimum octane numbers:
PUMP POSTED OCTANE NUMBER 86
Research Octane
Number
Most
Commonly
Used
an
the Past
91
Automotive
guotines
regular-leaded
or
lead-free meeting these m1mmum
octaAe
numbers may
be
uaed; however, best results will be obtained on 40 hp and
under by ualng lead-free gasoline.
L,AMMABLE AND
ALWAYS STOP
PLAMES
OR
SPARK
fUEL
TANKS.
1101'1&
When
operating in any other
country
than the Umted States. Canada
or
AultraJ;-. any
gao/me
may be used whtch
will
sattsfactonly operate an
eutomobil•
eng~,.
FUEL
MIXTURE
1 part approved
lubncant
to
50
parts
gasoline
(3
Gal Tank) 1/2
pmt
lubncant
to 3
gallons
(2-1
/2
lmpenal)
of
gasoltne
(6
Gal Tank) 1 pmt
lubncant
to 6
qallons
(5 Imperial)
of
gasoline
.
FUEL
MIXING
INSTRUCTIONS
Fuel
mixmg
1nstruct1ons
for
EVINRUDE
LUBRICANT
or
other
BIA
cert1f1ed
TC-W
lubncants
:
A
SAFETY
WARNING:
TO
PREVENT
SPILLING
FUEL
IN
BOAT
REMOVE
~PORTABLE
FUEL
TANK
WHEN
REFUELING.
GASOLINE
IS
HIGHLY
FLAMMABLE
• ALWAYS
MIX
IN
WELL
VENTILATED
AREA
Always use fresh gasoline.
PORT ABLE TANK
ABOVE 32°F
FUEL NOZZLE
,..._
__
MUST
CONTACT
METAL FUNNEL
BUILT-IN
TANK
Portable Tank -
Pour
lubricant
into
tank, add
gasoline
Replace f1ller
cap
secure
ly.
To
m1x
fuel,
t1p
tank
on
s1de
as
shown and back
to
upright
posttton
Bu1lt-in Tank - Use large funnel with a fine mesh
stramer
(100 mesh
or
fmer).
Pour
lubncant
slowly with the gasolme
as
tank is filled.
BELOW
32°F
Portable Tank - Pour
approximately
one
gallon
gasolme
tnto tank,
add
reqUired
lubncant. Replace
filler cap securely.
Thoroughly
mtx
by
shaking
tan.
Add
balance
of
gasol1ne.
Built-In
Tank - In separate
container
m1x
all
lubncant
needed wtth
one
gallon
or
more
of
gasoline Use large funnel with a fine mesh strainer (100
mesh
or
tmeq
Pour
th1s
mixture
slowly
w1th
gasoline as tank tS
filled
.
BREAK-~
PROCEDURE
The
50
:1
mixture
is used
during
break-tn. Use
only
EVINRUDE
LUBRICANT
or
other B lA certified
TC-W
lubncants.
OPERATION (FIRST HOUR). Do
not
operate engine
at
contmuous
full
power
tor
the first
hour
of
operation After
15
mmutes
of
slow
to
half
throttle
operation,
we
recommend a short burst
of
full throttle operatton every 5 to
10
mtnutes. Run at
full
throttle for about 90 seconds, then return
to
half
throttle
or
less
D
NOTE: Frequently check operatton
of
coolmg
system
dunng
break-:n A tme
spray
of
water dtscharged from exhaust relief
outlet
tnd
tcates
proper
operatton.
OPERATION (SECOND HOUR).
Bnng
boat
tnto
planmg
attitude
and reduce
power to three-quarter throttle (approximate)
while
mamtaming
planmg
att
iiu
ae At
tntervals
dunng
the second hour. apply full
power
tor
perrods
of
one
to
two
mtnutes
return1ng throttle
to
origmal setttng - three-quarter
throttle
for a
coolmg
penod
'
Avoid continuous full
throttle
operation
tor
extended
penods
durrr g the next
three hours.
L-
----------------------------
~~
----------------------------L-------------------------------
13
To Next Page
Loading...
