13-18-601 Page 5
TABLE OF CONTENTS
Maintain Compressor Reliability And Performance With Genuine
Gardner Denver Compressor Parts And Support Services .....................................................................1
Instructions For Ordering Repair Parts .........................................................................................................1
Warning – Prohibition – Mandatory Label Information..............................................................................2, 3
Safety Precautions........................................................................................................................................4
Index..............................................................................................................................................................6
List Of Illustrations.........................................................................................................................................7
Section 1, General Information .....................................................................................................................8
Section 2, Installation..................................................................................................................................13
Section 3, Starting & Operating Procedures...............................................................................................19
Section 4, Controls & Instrumentation ........................................................................................................26
Section 5, Compressor Lubrication - Separation, Filtration And Controls ..................................................39
Section 6 - Heat Exchangers (Oil, Air)........................................................................................................47
Section 7, Air Filter......................................................................................................................................53
Section 8, Shaft Coupling............................................................................................................................55
Section 9, Minimum Pressure/Check Valve................................................................................................58
Section 10, Inlet Control Valve....................................................................................................................60
Section 11, Pressure Relief Valve ..............................................................................................................62
Section 12, Ventilation Fans, Filters (Electrical Enclosure) ........................................................................64
Section 13, Motor Lubrication .....................................................................................................................65
Section 14, Maintenance Schedule ............................................................................................................66
Section 15, Troubleshooting .......................................................................................................................68
This book covers the following models:
KW PSIG
Air Cooled and
Water Cooled
Parts List
Controller
Manual
45, 50, 70 100 THRU 175 VS45-70A 13-18-500 13-17-600
NOTICE
Gardner Denver factory remanufactured replacement compressor
airend units are available from your authorized distributor, on an
exchange basis, for all rotary screw compressor units.
To Next Page
Loading...
