To Next Page

To Previous Page

190-01004-02 GTN 625/635/650 TSO Installation Manual

Rev. F Page C-1

APPENDIX C MECHANICAL DRAWINGS

C.1 Drawing List

The following drawings are included in this section.

 Figure C-1 GTN 625/635/650 CG and Mounting Rack Dimensions

 Figure C-2 GTN 625/635/650 Mounting Rack Installation

 Figure C-3 GTN 625/635/650 Recommended Panel Cutout Dimensions

 Figure C-4 GTN 625/635/650 Mounting Rack and Tab Alignment Detail

 Figure C-5 GTN 6XX Connector Layout Detail – Rear View

Through4
- Table of Contents9
- General Description19
- Introduction19
- Equipment Description20
- Physical Characteristics21
- Technical Specifications21
- Display22
- General Specifications22
- GTN GPS/SBAS Specifications23
- COM Specifications (GTN 635/650 Only)24
- VOR Specifications (GTN 650 Only)26
- LOC Specifications (GTN 650 Only)27
- Glideslope Specifications (GTN 650 Only)28
- Table 1-2. GTN Current Specifications29
- GPS/WAAS Antenna Requirements30
- License Requirements31
- Regulatory Compliance32
- TSO Authorization and Advisory Circular References32
  - Table 1-4. Hardware Part Numbers33
  - Table 1-5. GTN 6XX Hardware, CLD, and Software Compliance34
  - Table 1-6. TSO and ETSO Description38
- Non-TSO Functions39
- TSO System Functions and Software Levels39
- Table 1-9. System Functions40
- TSO/ETSO Deviations41
- AFM/AFMS/POH Considerations45
- FCC Grant of Equipment Authorization45
- Basemap Database49
- GTN Databases49
- Navigation Database49
- Chartview™ Database (GTN 725/750 Only)50
- Flitecharts® Database (GTN 725/750 Only)50
- Safetaxi® Database50
- Terrain Database50
- Fault Detection and Exclusion (FDE)51
- Obstacle Database51
- Aviation Limited Warranty52
Through52
- Aircraft Radio53
- GPS Antenna53
- Helicopter Installation53
- Installation53
- Limitations53
- Weather Products53
- IFR Installation of a GTN 625/63555
- Installation Overview55
- Introduction55
- Minimum System Configuration55
- VFR GPS Installation55
- IFR Installation of a GTN 65056
- Multiple Baro-Corrected Altitude Sources57
- Multiple True Airspeed Sources58
- GDL 88 Installation Considerations59
- Static Air Temperature Sources59
- Antenna Considerations60
- GPS Antenna Location60
- COM Antenna Location61
- Figure 3-1. GPS Antenna Installation Considerations62
- Electrical Bonding63
- Glideslope Antenna Location63
- Interference of GPS63
- VOR/LOC Antenna Location63
- Cabling and Wiring Considerations64
- GTN 625/635/650 Mounting Considerations64
- Air Circulation and Cooling65
- Compass Safe Distance65
- Installation Procedures67
- Unit and Accessories67
- Table 4-2. Standard Kit Accessories68
- GPS Antenna Options69
- Optional Accessories69
- Database Options70
- Miscellaneous Options70
- Enablement Cards71
- Optional Reference Material71
- Accessories Required but Not Supplied72
- Installation Materials Required but Not Supplied72
- Materials Required but Not Supplied (New Installations Only)72
- Optional Annunciation Panels73
- Special Tools Required74
- Coaxial Cable Installation75
- Table 4-5. Socket Contact Part Numbers76
- Equipment Mounting77
  - GTN Unit Insertion and Removal77
  - GDL 88 Page (Software Version 3.00 or Later)159
- Audio Configuration Page129
- Traffic Configuration Page129
- Main System Configuration Page130
- Table B-1. Type 1 Output Sentence Format190
- Aviation Output Sentence Type 2191
- Table B-2. Type 2 Output Sentence Format192
- Altitude Format 1 Sentence193
- Altitude Format 3 Sentence193
- Electrical Interface193
- Gtn Rs-232 Fuel/Air Data Input Format193
- Fuel Format 1 Sentence194
- Fuel Format 2 Sentence194
- FADC Format 1/Airdata Format 1 Sentence195
- Appendix Cmechanical Drawings199
- Drawing List199
  - Figure C-1. GTN 625/635/650 CG and Mounting Rack Dimensions201
  - Figure C-2. GTN 625/635/650 Mounting Rack Installation202
  - Figure C-3. GTN 625/635/650 Recommended Panel Cutout Dimensions203
  - Figure C-4. GTN 625/635/650 Mounting Rack and Tab Alignment Detail204
  - Figure C-5. GTN 6XX Connector Layout Detail – Rear View205
- Appendix Dinterconnect Diagrams207
- Drawing List207
- Figure D-1. GTN System Interface Diagram209
- Figure D-2. GTN 650 Typical Installation210
- Figure D-3. GTN 625 Typical Installation212
- Figure D-4. GTN 6XX Power Lighting Configuration Interconnect214
- Figure D-5. GTN 6XX – Antenna Interconnect215
- Figure D-6. GTN 6XX – Main Indicator Interconnect218
- Figure D-7. GTN 6XX - Autopilot Interconnect219
- Figure D-8. GTN 6XX - Traffic Interconnect220
- Figure D-9. GTN 6XX - Transponder Interconnect221
Figure D-10. Dual GTN to Single GDU Interconnect225
Figure D-11. GTN 6XX - ARINC 429 EFIS Interconnect226
Figure D-12. GTN - GDL 69/69A Interconnect228
Figure D-13. Audio Panel Interconnect229
Figure D-14. GTN 6XX - Air Data/Iru/Ahrs RS-232 Interconnect231
Figure D-15. GTN 6XX - Air Data/Iru/Ahrs ARINC 429 Interconnect233
Figure D-16. GTN 6XX - GAD 42 Interconnect234
Figure D-17. VOR/ILS Indicator Interconnect235
Figure D-18. GTN - RMI OBI Interconnect236
Figure D-19. GTN 6XX – WX-500 Interconnect237
Figure D-20. GTN 650 - DME Interconnect238
Figure D-21. GTN 650 – Remote DME Interconnect239
Figure D-22. Parallel 2 of 5 DME Tuning240
Figure D-23. Parallel Slip Code DME Tuning Interconnect241
Figure D-24. Reserved242
Figure D-25. GPS Annunciator Interconnect243
Figure D-26. NAV Source Select Annunciator Interconnect244
Figure D-27. TAWS/HTAWS Interconnect245
Figure D-28. Switches Interconnect246
Figure D-29. GTN 6XX - GDL 88/88D - Single GTN Installation Interconnect247
Figure D-30. GTN 6XX - GDL 88/88D - Dual GTN Installation Interconnect248
Figure D-31. GTN 6XX - GSR 56 Interconnect249
Figure D-32. Reserved250
Figure D-33. GTN 6XX - Radar Altimeter Interconnect251

Display Resolution	800 x 480 pixels
Display Type	LCD
COM Channels	2
Bluetooth	Yes
Wi-Fi	No
Audio Panel Interface	Yes
GPS Receiver	WAAS-enabled
Weight	1.2 lbs
Dimensions	6.25 inches
Power Consumption	15 W
Database	Jeppesen

Garmin GTN 635 Installation Manual

Table of Contents

Other manuals for Garmin GTN 635

Questions and Answers:

Garmin GTN 635 Specifications

Related product manuals