EN - 35
LONG-TERM STORAGE
1. Perform short-term storage procedures.
2. Lubricate as directed in Maintenance
Schedule on page 19..
3. Touch-up all scratched painted surfaces.
4. Remove and charge battery as directed
in Charging the Battery on page 25. Store
battery in a cool, dry, protected area.
5. Store unit in a cool, dry, protected area.
Do not store unit outdoors.
START-OF-SEASON
PREPARATION
1. Before adding fuel for the first time after
long-term storage, add fresh, stabilizer-
treated fuel to fuel tank and any fuel
containers with remaining fuel.
2. Charge and install the battery.
TROUBLESHOOTING
PROBLEM PROBABLE CAUSE CORRECTION
Engine does not
crank.
PTO engaged. Disengage PTO.
Parking brake disengaged. Engage parking brake.
Loose or corroded battery cables. Clean and tighten battery cables.
See Clean Battery on page 25.
Discharged battery. Charge battery. See Charging the
Battery on page 25.
Faulty starter. See your Gravely Dealer.
Blown fuse. Check main fuse and replace if
necessary.
Failed relay. Check relays in fuse block and
replace if necessary
Loose or broken wires. Check wire harness and
connections.
Weak battery. Check voltage and charge if
required. See Charging the Battery
on page 25.
Engine cranks but
does not start.
Fuel tank empty. Fill fuel tank. See Filling Fuel Tank
on page 15.
Faulty spark plug. Replace spark plug. Refer to
Engine Manual.
Air cleaner is plugged or dirty. Clean or replace air cleaner. Refer
to Engine Manual.
Fuel filter is dirty. Clean or replace fuel filter. Refer to
Engine Manual.
Faulty engine. Refer to Engine Manual or see
your Gravely Dealer.
Weak battery. Check voltage and charge if
required. See Charging the Battery
on page 25.
Oil pressure light
is on.
Oil pressure is low. Refer to Engine Manual.
Engine continues
to run when
ignition key is in
the off position.
Ignition ground wire disconnected. Connect ground wire to clean metal
surface.
Ignition switch failure. Replace ignition switch. See your
Gravely Dealer.
To Next Page
Loading...
