Gravely HR1536FL - Troubleshooting

GB - 34
Engine
TROUBLESHOOTING
Problem Probable Cause
Engine Will Not Start or Is Hard to
Start
Control levers not in the neutral position.
Key switch not in proper position.
PTO engaged.
Stale or improper fuel/fuel level.
Plugged fuel filter.
Plugged air intake filter.
Spark plug wire is loose or disconnected.
Spark plug not gapped correctly.
Blown 20-amp fuse (main power circuit).
Electrical problem - discharged battery.
Faulty relay or relay connection(s) (see Replacing Relays
(988147, 148) on page 31).
Choke adjusted incorrectly. See servicing dealer.
Engine Will Not Slow Idle Bent or kinked throttle cable.
Bent governor control.
Incorrect governor idle control.
Carburetor problems. See servicing dealer.
Engine Runs Rough or Stalls Plugged fuel filter.
Plugged air intake system.
Fuel cap vent dirty.
Stale or improper fuel/fuel level.
Spark plug not gapped correctly.
Replace spark plug.
Choke adjusted incorrectly. See servicing dealer.
Engine Knocks Engine oil level low.
Reduce load. (Slower ground speed.)
Fuel is bad. Fill tank with fresh fuel, correct octane.
Idle speed too slow.
Engine Overheats Clean cooling fins.
Low oil level.
Operating at slow idle – operate at full-throttle setting.
Cooling air intake screen is dirty.
Plugged air intake filter.
Operating at too fast ground speed for conditions.
Engine Lacks Power Plugged air intake system.
Plugged fuel filter.
Improper type of fuel. Drain tank and fill with correct fuel.
Clean cooling fins to help prevent overheating.
Replace spark plug.
Engine Uses Too Much Oil Find and correct oil leaks.
Incorrect engine oil.
Plugged oil filter.
Plugged air intake filter.