Home
Hill-Rom
Medical Equipment
P8020
Hill-Rom P8020 User Manual
4
of 1
of 1 rating
444 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
IV Pole—P2217
and ISS Transfer Pole—P15
8
Chapter 5:
Parts List
IV Pole—P2217 and ISS
T
ransfer Pole—P158
Figure 5-49. IV Pole—P2217 and ISS T
ransfer Pole—P158
Page 5 - 134
Hill-Rom®
Tr
ansport, Procedural, and
Specialty Stretchers
Service Manual (14
4386 REV 2)
345
347
Table of Contents
Default Chapter
5
Table of Contents
5
Chapter 1: Introduction
15
Purpose
15
Audience
15
Reference Documents
15
Document Symbols
16
Specifications
17
Physical Description
17
Electrical Specification
20
Environmental Conditions
20
Regulations, Standards, and Codes
22
Electromagnetic Emissions and Immunity Guidance
25
Model Identification
29
Safety Tips
30
Warning and Caution Labels
36
Chapter 2: Troubleshooting Procedures
37
Getting Started
37
Initial Actions
37
Scale-Problem and Solution Table
38
Function Checks
39
Brake/Steer
39
Hilow and Trendelenburg/Reverse Trendelenburg
39
Siderail
40
Back Section-Procedural (Without the Auto Cotour™ Feature), Transport, Trauma, or OB/GYN Stretcher Only
40
Push Handles (Optional)
40
Active Brake System (Optional)
41
Permanent IV Pole (Optional)
41
Scale (Optional)
41
Specific Function Checks-Procedural Stretcher
42
Knee Section (Optional)-Procedural Stretcher Only
42
Auto Contour™ Feature (Optional)-ON and off (Serial Numbers (S/N)
42
Before those that Start with K)
42
Features (Optional)
42
Specific Function Checks-Surgical Stretcher
43
Back Section
43
Headrest
43
Specific Function Checks-Electric Stretcher
43
Patient Controls (Located on the Siderails)
43
Nurse Controls (Located at the Foot End of the Stretcher)
45
Manual Back Section Articulation
46
Manual Knee Section Articulation
46
CPR Release
46
Trauma Stretcher Function Checks
47
Cassette Lift
47
OB/GYN Stretcher Function Checks
47
Foot Support
47
Foot Section
47
Final Actions
47
Reduced Braking Ability
48
Loss of Corner Steer
49
Steering Plus™ Steering System Does Not Operate Correctly
50
Stretcher will Not Go into Neutral Position
51
Reduced Pedal Pumps
52
Stretcher will Not Lower
53
Siderail Does Not Operate Correctly
55
Procedural (Without the Auto Contour™ Feature), Transport, Trauma, or OB/GYN Stretcher-Back Section Does Not Raise or Lower Correctly
56
Push Handle Malfunction
57
Permanent IV Pole Does Not Raise or Lower Correctly
58
Procedural or Surgical Stretcher-Knee Section will Not Raise or Lower
59
Scale Display Does Not Come on
60
The Weight Shown on the Scale Display Is Not Correct
61
The Weight Shown on the Scale Display Is Flashing
62
The Scale Display Flashes Hands Off, then CALC, and then
63
The Scale Display Flickers or Shows Partial Characters
64
Procedural Stretcher-Auto Contour™Feature with On/Off Controls
65
Does Not Raise or Lower Correctly
65
Procedural Stretcher-Auto Contour™ Feature or Backsaver Fowler® Feature Does Not Raise or Lower Correctly
66
Surgical Stretcher Back Section-Release Handle/Gas Spring Malfunction
67
Surgical Stretcher Articulating Headrest-Push Handle Release/Gas
68
Spring Malfunction
68
Electric Stretcher-Back Section Does Not Raise or Lower Electrically
69
Electric Stretcher-Knee Section Does Not Raise or Lower Electrically
70
Electric Stretcher Back Section-Manual Articulation
71
Electric Stretcher Knee Section-Manual Articulation
72
Trauma Stretcher Cassette Lift Handle Malfunction
73
OB/GYN Stretcher-Foot Supports Malfunction
74
OB/GYN Stretcher-Foot Section Does Not Release Correctly
76
Error 0 Shows on the Scale Display
77
Error 1 Shows on the Scale Display
78
Error 2 Shows on the Scale Display
79
Error 3 Shows on the Scale Display
80
Error 5 Shows on the Scale Display
81
Error 6 Shows on the Scale Display
82
Active Brake System-Reduced Braking Ability
83
Chapter 3: Theory of Operation
85
Electrical System (Electric Stretcher)
85
Control Board
85
Power Supply
85
Input Circuit
86
Logic
86
Comparator Circuit
86
LED Outputs
87
Relay Outputs
87
Potentiometer Calibration Board
87
Electric Stretcher Wiring Diagrams
88
Scale System (Optional for the Procedural, Electric, and Trauma Stretchers)
90
Load Beams
90
Scale P.C. Board
90
Display P.C. Board
91
Display Membrane Switch Panel
92
Chapter 4: Removal, Replacement, and Adjustment Procedures
95
Tool and Supply Requirements
95
Procedural (P8000), Surgical (P8010), Trauma (P8040), or OB/GYN (P8050) Stretcher-Siderail
97
Switch the Procedural (P8000) or Trauma (P8040) Stretcher Siderail to the Opposite Side of the Stretcher
100
Electric (P8020) Stretcher-Siderail
101
Transport (P8005) Stretcher-Siderail Latch
105
Transport (P8005) Stretcher-Siderail Tube
107
Procedural (P8000), Surgical (P8010), Electric (P8020), Trauma (P8040), or OB/GYN (P8050) Stretcher-Siderail Latch
109
Procedural (P8000), Surgical (P8010), Electric (P8020), Trauma (P8040), or OB/GYN (P8050) Stretcher-Siderail Tubes
111
OB/GYN (P8050) Stretcher-Patient Grip Handle
115
Upright Tube
117
Electric (P8020) Stretcher-Patient Control Switch
121
Electric (P8020) Stretcher-Nurse Control Switch
123
Electric (P8020) Stretcher-Control Board
125
Electric Stretcher-Potentiometer
128
Electric Stretcher-Power Cord Assembly
132
Procedural (P8000), Transport (P8005), Trauma (P8040), or OB/GYN (P8050) Stretcher-Back Section Gas Spring
135
Surgical (P8010) Stretcher-Back Section Gas Spring
139
Surgical (P8010) Stretcher-Articulating Headrest Gas Spring
142
Procedural (P8000) or Surgical (P8010) Stretcher-Knee Screw Assembly
145
Electric (P8020) Stretcher-Knee Drive Assembly
147
Electric (P8020) Stretcher-Head Drive Assembly
150
Electric (P8020) Stretcher-CPR Release Cable Assembly
154
Upper Frame and Base Shroud
158
OB/GYN (P8050) Stretcher-Upper Frame Catch Shroud
163
OB/GYN Stretcher-Foot Support Mechlok® Device
165
OB/GYN Stretcher-Foot Support Gas Spring
168
Caster
172
Caster Brake Adjustment
174
Brake/Steer Pedal Adjustment
175
Hydraulic Cylinder
176
Steering Plus™ Steering System Assembly
182
Electric Stretcher-Fuse
186
Scale-Batteries
188
Scale-Load Beam
190
Scale-Display or Scale P.C. Board
203
Active Brake System
205
Active Brake System-Neutral Detent
208
Stow-Away Push Handle (Stretchers with the Integrated Oxygen Tank Storage)
210
Chapter 5: Parts List
213
Service Parts Ordering
213
Exchange Policy
215
In-Warranty Exchanges
215
Out-Of-Warranty Exchanges
216
Warranty
217
Recommended Spare Parts
219
Caster and Base Shroud
220
Base Assembly-Side Pedal
222
Base Assembly-Side Pedals with End Brake and Steer
226
Base Assembly-End Pedals
230
Base Assembly-Steering Plus™ Steering System
234
Upper Frame Assembly-Transport (P8005) Stretcher
236
Upper Frame Assembly-Procedural (P8000) Stretcher
240
Upper Frame Panel Assembly-Procedural (P8000) Stretcher
244
Upper Frame Assembly-Surgical (P8010) Stretcher
248
Surgical (P8010) Stretcher-Articulating Headrest
252
Upper Frame Assembly-OB/GYN (P8050) Stretcher (Sheet 1 of 2)
254
Upper Frame Assembly-OB/GYN (P8050) Stretcher (Sheet 2 of 2)
258
Upper Frame Panel Assembly-OB/GYN (P8050) Stretcher
260
Upper Frame Assembly-Trauma (P8040) Stretcher
264
Upper Frame Panel Assembly-Trauma (P8040) Stretcher
268
Upper Frame Labels-Trauma (P8040) Stretcher
270
Upper Frame Assembly-Electric (P8020) Stretcher
272
Electric (P8020) Stretcher-Mattress Weldment
276
Electric (P8020) Stretcher-Head and Knee Drive Assembly
278
Electric (P8020) Stretcher-Head Drive/Cpr Assemblies
280
Electric (P8020) Stretcher-Gearbox Assembly
282
Electric (P8020) Stretcher-Cable/Wire Routing
284
Electric (P8020) Stretcher-Cable/Wire Assemblies
286
Electric (P8020) Stretcher-Control Board Assembly (120 V AC and
288
Upper Frame-Auto Contour™ and Backsaver Fowler® Features
290
(S/Ns before J134AN7176 (Sheet 1 of 2))
290
(S/Ns before J134AN7176 (Sheet 2 of 2))
292
Upper Frame-Auto Contour™ and Backsaver Fowler® Features
292
(S/Ns J134AN7176 and after (Sheet 1 of 2))
296
Upper Frame-Auto Contour™ and Backsaver Fowler® Features (S/Ns J134AN7176 through those that Start with K (Sheet 2 of 2))
298
Upper Frame-Auto Contour™ and Backsaver Fowler® Features
298
(S/Ns that Start with K and After)
302
Scale System
306
Active Brake System
308
Integrated Oxygen Tank Storage System
310
Stow-Away Push Handles and Utility Tray (Stretchers with the Integrated Oxygen Tank Storage)
312
Procedural (P8000) and Trauma (P8040) Stretchers-Siderail Assembly
314
Surgical (P8010) Stretcher-Siderail Assembly
318
Electric (P8020) Stretcher-Siderail Assembly
322
OB/GYN (P8050) Stretcher Siderail-Assembly
326
Pole Module
330
Pole
332
Head/Footboard-P4120CT
334
Convertible Footboard-P350CT
336
Transporter-P491
338
IV Transporter—P491
338
Liquid Oxygen Tank Holder-P273
340
Oxygen Tank Holder-P276
341
Oxygen Tank Holder Bracket-P27604
342
Horizontal Oxygen Tank Holder-P27603
343
ISS Socket Adapter-P163
344
Pole-P2217 and ISS Transfer Pole-P158
346
IV Pole—P2217 and ISS Transfer Pole—P158
346
Security Straps-P349
348
Push Handles
350
Armboard-P344AT
352
Stirrup Assembly-P347AT
354
Trauma Stretcher Upright Chest Assembly-P279AT
356
Trauma Stretcher Lateral Cassette Holder-P264
358
Surgical Stretcher PACU Extender-P261
360
Surgical Stretcher Head Positioning Strap-P449
363
Surgical Stretcher Superior Wrist Rest-P262A01
364
Surgical Stretcher Temporal Wrist Rest-P262A02
366
OB/GYN Stretcher Integrated Fiber Optic Exam Light-P7915AT
368
OB/GYN Stretcher Placenta Basin-P265
370
OB/GYN Stretcher Telescoping Calf Support-P35745AT
372
Hill-Rom® Transport, Procedural, and Specialty Stretchers Service Manual (144386 REV 2)
374
Mattresses
374
Chapter 6: General Procedures
375
Cleaning and Care
375
General Cleaning
375
Steam Cleaning
376
Cleaning Hard to Clean Spots
376
Disinfecting
376
Spray Wash (Not Applicable to Electric (P8020) Stretcher, OB/GYN (P8050) Stretcher with the Optional Exam Light Installed)
377
Mattress Draping (OB/GYN Stretcher)
378
Component Handling (Electric Stretcher and Stretchers with the Scale Option)
378
Boards
379
Preventive Maintenance
379
Preventive Maintenance Schedule
380
Preventive Maintenance Checklist
387
Chapter 7: Accessories
389
Stretcher Accessories
389
Infusion Support System (ISS) Transfer Pole (P158)
391
Pole (P2217)
392
Permanent IV Pole
393
Patient Tray (P490)
394
Footboard (P4120CTM07)
395
Convertible Footboard (P350CT)
396
Transporter (P491)
398
Oxygen Tank Holder (P27601)
401
Liquid Oxygen Tank Holder (P273)
402
Push Handles
403
Chart Holder (P361)
405
Transport Straps (P349)
406
Utility Tray (P297A01/A02)
407
Armboard (P344BT)
409
Upright Chest Cassette Holder (P279AT)
411
Lateral Cassette Holder (P264)
414
Ankle Stirrups (P347AT)
415
PACU Extender (P261)
417
Superior Wrist Rest (P262A01)
419
Temporal Wrist Rest (P262A02)
421
Gas Delivery System (P263)
423
Head Positioning Strap (P449)
425
Placenta Basin (P265)
427
Telescoping Calf Supports (P35745AT)
429
Integrated Fiber Optic Exam Light (P7915AT)
432
Headboard Assembly (P4120CT)
439
Foot Extender Pad (P929G1/2)
440
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Hill-Rom P8020 and is the answer not in the manual?
Ask a question
Hill-Rom P8020 Specifications
General
Brand
Hill-Rom
Model
P8020
Category
Medical Equipment
Language
English
Related product manuals
Hill-Rom P8005
444 pages
Hill-Rom P8000
444 pages
Hill-Rom P8010
444 pages
Hill-Rom P870
231 pages
Hill-Rom P8400
355 pages
Hill-Rom RESIDENT P872
178 pages
Hill-Rom P500
54 pages
Hill-Rom P1840
112 pages
Hill-Rom Volara PVL1
116 pages
Hill-Rom The Vest P205
80 pages
Hill-Rom CareAssist P1170
344 pages
Hill-Rom CareAssist Bed P1170
54 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
