EasyManua.ls Logo

Husqvarna TE 125 EU 2015 - User Manual

Husqvarna TE 125 EU 2015
130 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
OWNER'S MANUAL 2015
TE 125 EU
TE 125 US
TE 250 EU
TE 250 AU
TE 250 US
TE 300 EU
TE 300 AU
TE 300 US
Art. no. 3402022en

Table of Contents

Questions and Answers

  • M
    Mark KnoxAug 17, 2025
    How to troubleshoot why my Husqvarna Motorcycle engine cannot be cranked (electric starter)?
    • C
      Cynthia WalkerAug 17, 2025
      If your Husqvarna Motorcycle engine cannot be cranked using the electric starter, it could be due to several reasons. First, rule out any operating errors by going through the engine starting steps. If the battery is discharged (All TE 250/300), recharge it, check the charging voltage, and check the closed current. A blown main fuse (All TE 250/300) could also be the culprit; remove and reinstall the main fuse. Additionally, the starter relay or the starter motor might be faulty, so check both.
  • M
    Michael GordonAug 20, 2025
    Why does my Husqvarna Motorcycle engine overheat?
    • G
      garciaedwardAug 20, 2025
      If your Husqvarna Motorcycle engine overheats, there are several possible causes. Check the cooling system for leakage and ensure the coolant level is correct. If there's too little air stream, switch off the engine when stationary. Dirty radiator fins should be cleaned. If there's foam formation in the cooling system, drain and refill the coolant. Also, inspect the cylinder head and cylinder head gasket for damage. Finally, check for any bent radiator hoses and replace if necessary.
  • J
    Jonathon FryeAug 27, 2025
    Why does my Husqvarna Motorcycle engine stall or pop into the carburetor?
    • M
      Maurice ReedAug 27, 2025
      If your Husqvarna Motorcycle engine stalls or pops into the carburetor, it could be due to a lack of fuel. Turn the fuel tap handle to the ON position and refuel if necessary. The engine might be taking in bad air, so check the intake flange and carburetor for tightness. Also, make sure the connector or ignition coil isn't loose or oxidized; clean the connector and treat it with contact spray.
  • E
    Elijah JenkinsAug 30, 2025
    Why does my Husqvarna TE 125 EU 2015 Motorcycle engine have no idle?
    • S
      Steven GrimesAug 30, 2025
      If your Husqvarna Motorcycle engine has no idle, several factors could be the cause. An idling jet blocked can prevent the engine from idling, so check or set the carburetor components. If the adjusting screws on the carburetor are distorted, adjust the idle speed. A defective spark plug can also cause idling issues, so replace the spark plug. Lastly, a defective ignition system can be the culprit, so check the primary and secondary windings of the ignition coil, and check the spark plug connector.
  • J
    John DawsonSep 3, 2025
    Why is gear oil coming out of the vent hose on my Husqvarna TE 125 EU 2015 Motorcycle?
    • Y
      Yolanda HansonSep 3, 2025
      If gear oil is exiting at the vent hose of your Husqvarna Motorcycle, it's likely because too much gear oil was added. Check the gear oil level.
  • C
    Christopher SanchezSep 6, 2025
    What does it mean if my Husqvarna TE 125 EU 2015 emits white smoke (steam) in the exhaust gas?
    • C
      Charles WardSep 6, 2025
      If you notice white smoke emission (steam in exhaust gas) from your Husqvarna Motorcycle, it could be due to a damaged cylinder head or cylinder head gasket. Check these components for damage.
  • T
    thomas15Sep 10, 2025
    What could cause my Husqvarna TE 125 EU 2015 engine to have too little power?
    • M
      Mark PatelSep 10, 2025
      If your Husqvarna Motorcycle engine has too little power, it could be due to a damaged diaphragm or reed valve housing. Check these components.
  • E
    Emily KingNov 13, 2025
    What to do if my Husqvarna Motorcycle engine turns but does not start?
    • J
      Jonathan HortonNov 13, 2025
      If your Husqvarna Motorcycle engine turns over but won't start, several factors could be at play. First, ensure you're following the correct starting procedure. If the motorcycle has been stored for a while, old fuel in the float chamber might be the issue; in this case, empty the carburetor float chamber. Check for any interruptions in the fuel feed by inspecting the fuel tank breather and cleaning the fuel tap. Also, check or set the carburetor components. A spark plug that's oily or wet should be cleaned and dried, or replaced if necessary. Make sure the spark plug electrode gap is correctly adjusted to 0.60 mm (0.0236 in). A fault in the ignition system or a short circuit in the wiring harness could also be the cause, so check the kill switch and the ignition system. Finally, ensure th...
  • K
    Karen PhillipsNov 23, 2025
    What causes a Husqvarna Motorcycle engine to not speed up?
    • J
      jamesgarrettNov 23, 2025
      If your Husqvarna Motorcycle engine does not speed up, several issues could be responsible. A carburetor running over due to a dirty or worn float needle can cause this; in that case, check or set the carburetor components. Loose carburetor jets can also be the problem, so check or set the carburetor components. A fault in the ignition system can prevent the engine from speeding up, so check the ignition system. Check the fuel tank breather, clean the fuel tap, and check or set the carburetor components to ensure proper fuel feed. A very dirty air filter can restrict airflow, so clean the air filter and air filter box. Lastly, a leaky or deformed exhaust system, or too little glass fiber yarn filling in the main silencer, can cause this; check the exhaust system for damage and change the g...

Summary

Safety Advice

Safety Advice

General instructions for safe operation and maintenance of the motorcycle.

Safe Operation

Guidelines for operating the vehicle safely and responsibly.

Controls

Clutch Lever

Location and function of the clutch lever on the handlebar.

Hand Brake Lever

Location and function of the hand brake lever.

Throttle Grip

Location and function of the throttle grip on the handlebar.

Emergency OFF switch (All TE AU)

Location and function of the emergency kill switch.

Riding Instructions

Checks and maintenance steps when preparing for use

Essential pre-ride checks for safe operation and vehicle condition.

Braking

Instructions and warnings related to effective and safe braking techniques.

Service Schedule

Service schedule

Regular maintenance intervals and tasks for optimal performance.

Tuning the Chassis

Checking the basic chassis setting with the riders weight

Adjusting suspension for rider weight and optimal handling.

Adjusting the spring preload of the shock absorber

Procedure for adjusting rear shock absorber spring preload.

Brake System

Checking the front brake fluid level

Procedure to check and maintain front brake fluid level.

Checking the rear brake fluid level

Procedure to check and maintain rear brake fluid level.

Wheels, Tires

Checking the tire air pressure

Correct tire air pressure for optimal riding and safety.

Tuning the Engine

Carburetor - adjusting the idle speed

Steps to adjust the engine's idle speed for smooth operation.

Service Work on the Engine

Checking the gear oil level

Procedure to check the engine's gear oil level.

Changing the gear oil

Steps for draining and refilling the engine's gear oil.

Troubleshooting

Technical Data

Engine tightening torques

Specifications for tightening engine component screws and bolts.

Chassis tightening torques

Specifications for tightening chassis component screws and bolts.

Substances

Engine oil (SAE 10 W;40)

Recommended engine oil specifications and usage guidelines.

Husqvarna TE 125 EU 2015 Specifications

General IconGeneral
Engine TypeSingle-cylinder, 2-stroke
Displacement124.8 cc
Bore x Stroke54 x 54.5 mm
Compression Ratio12.5:1
StarterKick
Transmission6-speed
Rear SuspensionWP Monoshock
Weight98 kg
Fuel Tank Capacity8.5 liters
Fuel Capacity8.5 liters
Fuel SystemKeihin PWK 36
IgnitionElectronic
FrameChromium Molybdenum Steel
Front SuspensionWP-USD, Ø 48 mm
Front Brake260 mm disc
Rear Brake220 mm disc
Front Tire80/100-21
Seat Height960 mm

Related product manuals