General
WARNING
Before working on or near the mast, see Safety
Procedures When Working Near Mast in this
manual.
NOTE: Hoses have a service life that is determined
by application and time. Install a new hose if the
hose is leaking, worn through, or damaged. A hose
has been damaged if the hose cover is cracked,
exposing the braiding, or if the hose has been
kinked or crushed, or if the hose is no longer
flexible. Install a new hose if the hose has been
tensioned beyond the adjustment range. If
necessary, make a comparison to a new hose that is
the correct replacement for the hose you are
inspecting.
This section contains the repair procedures for the
Two-Stage, Limited Free-Lift (LFL) mast with
serial numbers A389 and A399 and the Three-
Stage, Full Free-Lift (FFL) mast with serial
numbers A387 and A397. The mast serial number
is located on the right side of the outer mast. Other
information about the mast can also be found in
this area. See Figure 1.
Procedures to repair the carriage, replace the forks,
and adjust the lift chains, carriage, and mast are
also covered in this manual.
4000 SRM 1999 General
1
To Next Page
Loading...