B
MAINTENANCE & LUBE CHARTS
en-57
Safety, Operation, & Maintenance Manual
Lithium
MAINTENANCE AND LUBRICATION CHARTS
GENERAL __________________________________________________________
• Always clean the grease fitting before and after lubricating.
• Lubricate with grease that meets or exceeds NLGI Grade 2 LB specifications. Apply grease with a manual grease
gun and fill slowly until grease begins to seep out. Do not use compressed air guns.
• Periodically apply a small amount of lithium based grease to the seat runners.
• For smooth operation of all levers, pivot points and other friction points that are not shown on the lubrication chart
apply several drops of SAE 30 oil every 40 hours or as required.
• Grease fittings (F1) every 50 hours, fittings (F2) every 100 hours, and fittings (F3) every 200 hours.
MAINTENANCE CHARTS _____________________________________________
A - Add or Adjust C - Clean I - Inspect L- Lubricate R - Replace AR - As Required
* Indicates initial service for new machines.
** Not required unless engine problems occur.
*** Every 300 hours or Yearly, whichever occurs first.
**** Every 500 hours or Yearly, whichever occurs first.
***** Every 300 hours or Yearly, whichever occurs first. Replace if coupler is loose or damaged.
WARNING
Before you clean, adjust, or repair this equipment,
disengage all drives, lower implements to the
ground, engage parking brake, stop engine and
remove key from ignition switch to prevent injuries
Recommended Service and Lubrication Intervals
Every
8-10
Hours
Every
25
Hours
Every
40-50
Hours
Every
100
Hours
Every
200
Hours
Every
300
Hours
Every
400
Hours
Every
500
Hours
Every
1000
Hours
See
Page
Lubri-
cant
Type
Battery Electrolyte (Bat-
tery)
I A
Battery Fluid (Battery) I/A
Belts I-A* I-A
Brake Resistors I/C
Front Axle Fluid I/A 63 III
Front Axle Hub I*** 64
Electrical System I/C 71
Grease Fittings - F1 L 58 I
Grease Fittings - F2 L 58 I
Grease Fittings - F3 L 58 I
Parking Brake IC**** 65
Rear Wheel Bearings L I
Reel Motor Coupler IC****
*
Steering Chain I/L V
Tires I-A 69
!
To Next Page
Loading...
Need help?
General
